tag:blogger.com,1999:blog-28108147918364077132024-03-17T00:16:26.424-07:00China Air and Naval PowerUnknownnoreply@blogger.comBlogger335125tag:blogger.com,1999:blog-2810814791836407713.post-62479303506677630322017-01-07T17:27:00.000-08:002017-01-07T17:27:05.220-08:00Naval aviationPLAN's naval aviation arm has gotten a huge boost since the commissioning of CV-16. In the past year, this has been especially more pronounced with more and more activities off CV-16. As PLAN is becoming more and more a blue water navy, this is expected to continue. Historically, PLAN's naval aviation wing is dominated by a lot of land based aircraft that are focused on nearby water. Outside of some naval helicopters, they were fixed wing aircraft that simply could not land on a ship. That's not a sign of a modern navy. It's well known that USN has more aircraft than USAF. More importantly, most of these aircraft are expected to be able to operated off surface combatants. So in order to become a modern navy, PLAN's air force needed to transform from a bunch of land based aircraft that can attack naval targets to ones that can take off/land on flat tops and carried to distant land. With that, we can take a look at the recent improvements in the operation of J-15s and naval helicopters.<br/>
<br/>
For the past month, CV-16 made a lot of news operating in a carrier group formation (with 3 052C/D, 2 054As and 1 Type 903A AOR) from its base all the way down to South China Sea. This fleet certainly does pack a lot of offensive fire power while providing adequate AAW and ASW protection. As it passed by Japanese islands and Taiwan, alarm bells understandably went off in those defence ministries. It might have even got some more play in US press if not for the news of Russian hacking. Against countries around South China Sea, this would present a lot of hard power. Back when Chinese naval planners had first thought about carriers, this is exactly what they had envisioned. Of course, this carrier strike group would present a lot of power projection even further away from Chinese waters, but it has not travelled that far yet.<br/>
<br/>
As impressive as this strike group was, the air wing operation off CV-16 was the focal point. It seems to most PLAN watchers that PLAN has been able to developing carrier aviation operations reasonably quickly since CV-16 was first commissioned. In the 4 years since that time, we have seen more intensive take-off and landings from CV-16. CV-16 was even declared fully operational and combat ready earlier this year. It seemed a little premature at the time, since how would one quantify the move from training to combat ready. This most recent deployment does seem to resemble a combat ready carrier operation. First of all, we saw more aircraft on deck than at any time before. There were pictures showing 13 J-15s and 1 Z-18 on deck at the same time. I am sure more aircraft were in the hangar at the time. There were also pictures showing 7 helicopters and multiple J-15s at the same time. That's definitely something Russian Navy is not capable of carrying out at the moment. Secondly, the J-15s appeared to have been taking off and landing in very quick succession based on the still photos that we saw. There were 2 J-15s set up in take off location with more J-15 looked ready to be moved over after each takeoff. We have yet to see night time operation photos of J-15, but this reportedly have also taken place in South China Sea. After that, the next big hurdle for J-15 operations would be taking off and landing in bad weather and high sea state conditions. What they have achieved thus far in terms of flight operation intensity at different times of day is something they didn't even train on land before PLAAF's modernization efforts. And finally, we have seen a variety of helicopters and J-15s set up for different missions. J-15s have been shown carrying AAMs and AShMs for air superiority roles and anti-shipping roles. An EW variant of J-15 was developed and flew last year. We have also seen J-15 with UPAZ-1A refueling pod under centerline to allow for buddy to buddy refueling. While this is not ideal, J-15s have already shown more multi-role capabilities than Su-33 showed with Adm K carrier.<br/>
<br/>
We saw 3 Z-18J, 1 Z-18, 1 Z-18F and 2 Z-9S at the same time. PLAN has long been hampered by the size of Z-8/18 series of helicopters because they are too large to fit in the hangar of most ships under 20,000 ton. Up to this point, only Type 071 LPDs have been effectively using Z-8 helicopters. On CV-16, the additional payload and internal space of Z-18 helicopters make them a good interim solution until China develops fixed wing ASW/AEW platforms that can takeoff/land on carrier. Even when that becomes available, the STOBAR carriers will still rely on helicopters. China had purchased Ka-31 AEW helicopters from Russia, but prefer to use Z-18J on CV-16. I think that would indicate Z-18J is a better platform for AEW missions due to additional payload and space (for more equipments and personnel). Along the same line, Z-18F is installed with a powerful dipping sonar, large surface search radar, FLIR/TV turret, 30 openings for sonobuoys and 4 pylons (that can carry Yu-7K torpedoes and YJ-9 AShM). It also has more internal space to carry more electronic equipment and personnel than Ka-28. We have also seen Z-8JH on CV-16 as a SAR helicopter with medical equipment on board. This a wide range of helicopters should be able to adequately support CV-16/17 in the near term.<br/>
<br/>
Since Z-8/18 couldn't fit in the hangars of larger surface combatants like 052C or 054A, PLAN have been forced to use Ka-28/31 or Z-9C/D helicopters. Neither of these options are the perfect fit. Type 054A would be better served with a larger helicopter that can carry more equipment and fly further. Type 052C/D have been able to use Ka-28 for ASW missions and Ka-31 to search both enemy aircraft and ships. Even so, it would be better if they had a similar sized domestic option that can be fit with the latest Chinese subsystems. It's clear that PLAN prefers its own electronics over Russian ones. Ka-31s were purchased recently, so I'd expect PLAN to continue to carry them on 052 series and possibly 055 series in the future to improve targeting against ships, sea skimming missiles and low flying aircraft. Z-9C and Ka-28 will be replaced by something that is more advanced. Currently, China is doing flight testing on Z-20 and AC-352 helicopters. AC-352 is now equipped with domestic produced WZ-16 turboshaft. It's probably going to be the most advanced helicopter of its class. It has a lot of military potential in the role of utility or naval helicopters. I think that in the long run, it will be a good replacement for Z-9C on 054A sized ships. Z-20 is a little larger and uses domestically developed WZ-10 series of turboshaft. It is developed to serve the role of blackhawk helicopter in PLA. Initially, I think Z-20 will be deployed in that role. Further along, I think a naval version of Z-20 can be developed (similar to SH-60 sea hawk) to serve as Ka-28 replacement. If PLAN deems the cost to be too high, they may decide to only develop one of Z-15 and Z-20 in the naval role, since they are similar in size.<br/>
<br/>
Several years ago, naval helicopter was regarded as one of the weakest areas for PLAN. I think it still remains that way, but the deployment of Z-8/18 on CV-16, Type 071 and other large ships have vastly improved this area. Ka-31 purchase was expected to provide AEW support for CV-16, but have found themselves on 052C/D instead. Once Z-15 and/or Z-20 naval versions get developed in a few years, this will have solved one of the remaining glaring holes with PLAN.
Unknownnoreply@blogger.com56tag:blogger.com,1999:blog-2810814791836407713.post-14261994771453341992016-12-25T14:07:00.000-08:002016-12-25T14:07:30.864-08:00Notable things from 2016This was a year of many major events for PLAAF and PLAN. This was the year that China came a major or even dominant exporter of UAVs and dramatically expanded its activities in South China Sea with the installation of HQ-9 SAMs. I will look into and review activities from different departments.<br/>
<br/>
This year, PLAN declared that CV-16 is finally combat ready. Throughout much of the year, we saw that the intensity of the flight operations were going up. By the end of the year, CV-16 went on a major exercise where it did much live firing exercises. During this exercise, PLAN went through a much more intensive flight activity with J-15s set up to takeoff in rapid succession. We saw as many as 13 J-15s and 1 Z-18 on board CV-16. The J-15s have been carrying anti-ship missiles as well as anti-air missiles. One of them was even carrying a UPAZ-1A refueling pod. This is the largest air wing we have ever seen on board CV-16. It's hard to say how many more aircraft could even be fit on board CV-16, since Admiral Kuznetsov class has rarely gone with its full complement of aircraft. At this point, at least 21 J-15s that have gone into service by now, so many more could be in the hangar area awaiting takeoff. As this was happening, Type 001A, the first domestically produced carrier, was slowly taking shape in Dalian shipyard. As expected, Type 001A CV-17 looks to be the exact replica of CV-16 in dimensions. CV-17's island is a little smaller than that of CV-16 from what we can see. I also would expect the interior of the carrier to be refined and improved from CV-16. And finally, the CATOBAR variant of J-15 (J-15A) flew for the first time, being powered by WS-10H engines. The 2nd domestic carrier, Type 002, is expected to be a CATOBAR carrier.<br/>
<br/>
As carrier activity heated up this year, more and more blue water surface combatants also joined service. The first Type 055 modules were photographed from JN shipyard this year. They probably won't be launched until 2nd half of next year, so we do not know their exact sizes yet. I wrote an entry previously on how I think Type 055 will look like. Initially, at least 2 Type 055s have been identified at JN shipyard. There has not been any Type 055 modules at Dalian shipyard, but I would expect it to also participate. A new series like Type 055 comes with more risks, so Type 052D construction continues to be very hectic. No. 117, the 5th 052D, was shown in the past month in North Sea Fleet. Basically, we have a full flotilla of 4 052Ds in service with South Sea Fleet and another one that is about to join service. Aside from that, at least 2 more 052Ds are on sea trials and another 4 are fitting out at the shipyards (2 at Dalian and 2 at JN). The 052D production run seems to already have reached more units than I expected (which was 12). A lot of progress was also made among the destroyers going through extensive weapon system upgrades. The lone Type 051B destroyer, No. 167, recently went out for sea trials after long period of time in the shipyard. A lot of progress has also been made in No. 136, the first Sov destroyer. It will be interesting to see the exact upgrades that have been performed over the next year.<br/>
<br/>
Of the remaining surface combatants, the production run for Type 054A appears to be coming to a close. Only 2 Type 054As joined service earlier this year with 2 more ready to join service soon. Both HP and HD shipyard will move to other projects after the current batch is completed. They have both been very active with Type 056 production, as have Wuchang and LiaoNan shipyard. At least 6 Type 056s have already joined service this year. Up to this point, at least 40 of them have at least been launched. About 12 to 13 Type 056s have been identified in both HP and HD shipyard, with another 9+ have been identified in each of the other 2. There may be 60 Type 056s by the end of its production run. There does seem to a lull in the production of larger ships. There were 1 Type 071 LPD, 1 Type 815A AGI and 3 Type 903A AOR joining service in the earlier part of this year, but HD shipyard hasn't launched any other large naval ships recently. PLAN may be moving on from these series of ships to newer classes. The first Type 901 AOR was launched at GSI shipyard and has recently gone on sea trials. It is much larger than Type 903A and far more suited for supplying a carrier group. There is also the rumoured Type 075 LHD class which should be noticed soon. I expect HD shipyard to carry the task of building this series. It remains to be seen if an upgrade Type 071A LPD will also start production. Production of Type 081 minesweeper and Type 082II minehunters also seemed to have drawn to a close.<br/>
<br/>
As I look at PLAN this year, the focus has mainly been on the development of carrier group. A lot of time and effort have been devoted to the construction of new carrier and building up naval aviation fleet. Type 055 and Type 056 series have also enjoyed a lot of attention, but other areas have begun to slow down. It appears that numerous branches of PLAN surface combatants have finished hardware modernization. PLAN is continuing to develop a fleet with more fire power and blue water capability. It should not be surprising that areas like MCM fleet, medium sized AORs, AGI fleet and icebreakers slowing down production after a while. Even PLAN's fleet of frigates have mostly completed modernization now that Type 054/As have taken over all the major flotilla.<br/>
<br/>
While PLAN's marquee project was making significant progress, PLAAF's marquee project J-20 also experienced much progress this year. The first LRIP version of J-20 appeared at the end of last year and made it's maiden flight this year. As the year went on, more photos of LRIP J-20 appeared. They were tested carrying various different missiles, fuel tanks and other ordinances. By the time of Zhuhai Airshow, J-20 made its first public appearance in a fly by. Not much was shown, but that is expected for a fighter jet that has yet to complete all of its flight and weapon testing. By the end of this year, FTTC formed a new 176th brigade for the first 6 J-20s to begin the process of expanding its flight envelope and developing tactics and training programs. The first 2 J-20s were officially handed over this month, but there have already been rumours of DACT between J-20 and 3rd generation fighter jet. Much of the rumours sounded like the early stories of F-22 vs F-15/18, so I will be keeping an eye out for more stories like this in 2017. At this point, it looks like J-20 will achieve IOC in 2017, which is just 6 years after it's first flight and 3 years after the first flight of No. 2011. A whole new series of missiles have been developed for J-20. J-10B/C are already in service with PESA/AESA radar along with a new generation of integrated avionics and combat system. One would imagine J-20 would be much further along, but it's unknown how that would compare to F-35 (often referred to as a flying computer). Either way, the largest question mark left for J-20 is its propulsion. WS-15 is still a couple of years away from design certification. Therefore, the initial J-20s are flying with under powered engines. It may be a while longer before we get details on exactly what kind of engines are powering these early J-20s. The J-31 project appears to have fallen much first behind. There were numerous reports in this year that both PLAAF and PLAN have rejected the current iteration of this aircraft. It looks like SAC is continuing to privately fund this project and recently flew the second prototype. Since J-20 is unlikely to be purchased in large number (probably in similar numbers of F-22), there will be a requirement for a lower cost 5th generation fighter jet. SAC is building a limited number of prototypes to continue to showcase an improved demonstrator. At some point, it is hoping to capture more funding from PLA in order to really ramp up the development work for J-31. It would be a sad day for SAC if it looses both the light 5th gen aircraft and 2nd generation naval aircraft project to CAC.<br/>
<br/>
The other major news in PLAAF this year was the entry into service of Y-20 transport. Two Y-20s were handed over to the first 4th division in June. More Y-20s may have been handed over by the end of the year. Ramping up the production of an aircraft the size of Y-20 is no easy task. Even Airbus and Boeing experience much difficulties in ramping up production level of new aircraft like A350 and B787 while trying to lower the production cost at the same time. I don't think Y-20 production needs to reach that level, but it will be a big challenge for XAC to go from building 1 Y-20 every 2 months to 2 Y-20s every month. The Y-20 platform is badly needed in PLAAF for various missions, so it's critical for XAC to be able to ramp up Y-20 production. Until then, PLAAF is reliant on 3 IL-78s and some H6U for refueling + various Y-8/9s for special mission platform. On the major question of propulsion, I think the initial batch is equipped with WS-18 engine. WS-20 seems to have already done a lot of testing, so it may be ready to equip Y-20 in the near future.<br/>
<br/>
As J-20 captured all of the spotlight this year, J-10C production has continued int he background. After the first batch of 55 J-10B was produced, there probably will be around that many J-10Cs being produced in this second batch. As many as 4 J-10B/C regiments have been formed on top of the J-10B/Cs servicing with 2 different FTTC brigades. Currently, close to 40 J-10s are produced every year. At the same time, the deal for 24 Su-35s with Russia was finally agreed to. The first Su-35 appears to have been delivered in the last couple of days. I know a lot of Chinese military fans are wondering why this was signed. It seems like PLAAF prefers Su-35 over J-11D and wanted another flanker regiment in the air superiority missions in service. Development work for J-11D has continued. It's major improvements over J-11B seems to be all related to electronics, so I don't think it should take too long for this aircraft to join service. Work on J-16 has also continued. A recent photo showed a second batch of J-16s under construction at SAC. Some from the first batch appears to be going through the testing process at FTTC. I have yet to confirm an official J-16 regiment. On the whole, SAC continues to look a step slower than CAC in production and development. It took a good 5 years (2008 to 2013) to go from J-10B's first flight to joining service with PLAAF. It took the same number of years for J-11B to go from first flight in 2002 to joining service with 2007. All of this happened while CAC had to divert precious resources to the J-20 project. More recently, it seems like CAC moved from J-10B to J-10C a lot more smoothly than SAC from J-11B to J-11D. In both cases, the major changes were all related to avionics and combat system. At some point, production version of J-10s will finally move to using WS-10 series of engines. The original WS-10 engines finally achieved production certification this year, which is quite a huge milestone. A couple of J-10Bs were fitted with WS-10B engines at the end of the first batch, but the J-10Cs have continued to be equipped with AL-31FN. The upgraded WS-10G engine, aka WS-10IPE?, supposedly achieved design certification year, so we should be seeing it join service soon. There are some speculations that we will a J-10D variant with this engine and some other upgrades, but that is to be seen. And finally, WS-13E engine achieved design certification this year. The second FC-31 prototype may be powered by this engine. It could also be used to power JF-17 and UCAV projects. So, I think this is one development that should be carefully watched.<br/>
<br/>
In all of the remaining areas, I think the explosion of UAV/UCAV exports this year has been quite fascinating. The CH series have now becomes the AK-47s of drones. Many of the middle Eastern countries have purchased some Chinese UAVs and put them into action. It remains to be seen which of the UAV prototypes tested in CAC and SAC airfields in the recent years will be put into service with PLA. There have also been a lot of movements on both army and naval helicopter forces. Most recently, Z-15 had its maiden flight with WZ-16 engine. This helicopter is expected to make its way into PLA at some point. Z-20 helicopter has been going through a lot of testing and may still be a couple of years away. China had been lacking a non attack helicopter between the 4 and 13 ton class for the longest time. Now, it will have two in a couple of years when both Z-15 and Z-20 are ready. They may not be both needed. Z-10 and Z-19 have continued to proliferate with Army Aviation. A more power attack helicopter is said to be under development. Newer turboshaft (WZ-10 and WZ-16) are now available as part of Z-15 and Z-20 project which could be used to power such an attack helo. Various Z-8 and Z-18 helicopter versions have shown up on CV-16 and Type 071 LPD. They are the mainstays of larger ships. The Kamov and Z-9C series of helicopters are still the work horses of PLAN rotary aviation forces for the destroyers and frigates. At some point, these helicopters will need to be replaced since Z-9Cs are too small whereas Ka-28s are too old.<br/>
<br/>
In many ways, PLAAF have grown in more areas than PLAN this year. Aerospace engine remains an area which holds back most PLAAF projects. The progress of J-20 projects has surprised many people. The Y-20 EIS is also very significant. Z-20 is also very far along in its production testing. After J-20, Z-20 and Y-20 join service, the final major ticket item is the H-20 bomber project. Can China go from a bomb truck like H-6K to a subsonic fly wing design similar to B-2. Of all the major ticket items, this appears to be the most challenging of all.Unknownnoreply@blogger.com42tag:blogger.com,1999:blog-2810814791836407713.post-7516808484814246062016-11-01T18:54:00.001-07:002016-11-01T18:54:05.278-07:00J-20 and other news from Zhuhai Air ShowChina made it official this week that J-20 is coming to Zhuhai air show. All of this is quite interesting when one compares this to how long before J-10 made its first visit to Zhuhai Air Show. Clearly, China has taken a more confident and transparent approach in its military programs in the past 10 years. At this point, J-20 has started Low rate initial production batches, but has yet to achieve IOC. To that end, AVIC must be confident enough in the progress of flight-testing program to allow J-20 to appear in China’s most prominent aerospace exhibition.<br/>
<br/>
A couple of years ago, PAK-FA had an epic failure when one of the prototypes had fire damage while delivering a flight performance in front of IAF officials. Certainly, the pilots were most likely instructed to put on a show to impress PAK-FA’s largest export client, but the aircraft was also clearly not up to task. The result of that embarrassing incident was extensive delays in the flight-testing program while that prototype was getting repaired. More recently, Russia finally officially adjusted the initial induction of PAK-FA to 2018. It had been obvious for quite a long time that they were not going to make end of 2016, since the fixed up prototype and new prototypes have just recently surfaced. I have not kept up to the progress of J-20 units, but it seems like the first LRIP frames may have already arrived at FTTC. FTTC should very soon start training with this new aircraft. IOC may be achieved by late next year. Of course, engine remains to be a major concern for the J-20 program. It’s still not known at this point what is powering aircraft. It would seem to be a special variant of AL-31FN, but this will be an interim solution until WS-15 is ready. At its induction, J-20 will be quite underpowered.<br/>
<br/>
Aside from J-20, other big-ticket items like J-10B, KJ-500, Y-20, Z-10K and H-6K will all be physically displayed in the air show. Since a real J-10B came, the serial number was finally allowed to show. Maybe after this appearance, China will allow J-10B pictures to be published without the serial numbers photoshoped. Zhuhai air show has traditionally been an occasion for China to show its latest UAV and missiles (many of which are still in conceptual stage). It will certainly be the case again this time around. While we have already seen well know UAVs like CH-5 and Wing Loong-2, we are also seeing new concepts that could very well make their mark in the export market. The latest one we saw is Cloud Shadow UAV which looks a lot like SkyWing UAVs that have already test flied.<br/>
<br/>
Finally, a recent national day parade in Turkmenistan showed that all of its SAMs, missiles, radar systems and UAVs are all imported from China. All of this is quite unexpected since Turkmenistan has traditionally been under the overwhelming presence and influence of Russia. At this point, China is clearly making inroads against Russia in many export markets.
Unknownnoreply@blogger.com14tag:blogger.com,1999:blog-2810814791836407713.post-37814907838073000192016-10-12T18:49:00.000-07:002016-10-12T18:49:03.039-07:00Looking at cruisers and Type 055When I read Pop3’s comments that an initial estimate of the Type 055 design’s displacement was over 20,000 ton, the first thought that came to my mind was Kirov class cruiser. Since the retirement of Iowa class, Kirov has been by far the largest non-carrier surface combatant. There has been numerous estimate of Type 055 size based on the land simulator in Wuhan. I want to look over cruisers from around the world and comparing them to what Type 055 might look like.
<br/><br/>
The first one to look at is Kirov class cruiser, which was built around the P-700 Shipwreck AShM. It is estimated to be 252 m long, 28.5 m in beam and 9.1 m draft for full load displacement of 28,000 ton. In order to achieve 30+ knots in speed, it was installed with nuclear and steam turbine propulsion (CONAS). As one could imagine, the propulsion unit takes up a lot of space. In terms of missiles, Kirov is installed with 20 P-700 AShM, 96 S-300F long range SAM, 128 SA-N-9 short range SAM and 40 SA-N-4 point defense SAM. It is also installed with 8 AK-630 or 6 Kashtan CIWS for last-ditch defense. And finally, it has one AK-130 main gun, ASW rocket launchers and torpedo tube launched torpedoes. At 20 knots operating on nuclear power, it has unlimited range. This allows Kirov class to operate by itself far from home base. However, such design requires additional storage space that would not be expected out of a normal surface combatant.
<br/><br/>
At the same time that Kirov was being built, the smaller conventionally powered Slava class Cruiser was also being built around the P-500 Bazalt AShM. It is estimated to be 186 m long, 20.8 m in beam and 8.4 m draft for full load displacement of 12,500 ton. In terms of missiles, Slava class is installed with 16 P-500 P-500 AShM, 64 S-300F long range SA and 40 SA-N-4 point Short range SAM. It is also installed with 6 AK-630 CIWS and a AK-130 main gun.
<br/><br/>
Looking at Slava class, I think it’s quite obvious why China was not interested in purchasing the almost completed 4th unit (Ukrayina) when the Ukrainians offered it for S600 million. The much smaller 051C carries 48 S-300F missiles (using 1 Top Dome FCR instead of 2 on Slava) along with 2 PJ-12 CIWS for air defense. Having a pair of 051Cs probably offers stronger area air defense than 1 Slava class. More importantly, 052C/052D has become a major success compared to the slightly larger, but less powerful 051C class. The size of the S-300F VLS along with the large and bulky top dome FCR took away the option of installing a hangar on 051C.
<br/><br/>
Turning our eyes away from former Soviet cruisers, KDX-3 is another very powerful cruiser currently in service. It is 165 m long, 21.4 m in beam and 6.25 m in draft for full load displacement of 11,000 tons. It is installed with 4 LM-2500 gas turbines along with 2 shafts in COGAG configuration allowing for 30+ knots in speed. In terms of missiles, it has 80 cell MK-41 VLS and 48 cell K-VLS for Korean LACM and ASROC. It is also equipped with 1 Goalkeeper CIWS and 1 RAM CIWS for point defense. And finally, it has a MK-45 main fun and 2 triple barrel torpedoes.
<br/><br/>
The Arleigh Burke class has similar layout to KDX-3. Flight IIA is 155 m long, 20 m wide and 9.3 m in draft for full load of 10,000 ton. It is also installed with COGAG propulsion (4 LM-2500 turbine + 2 shafts) and capable of 30+ knots. In terms of armament, it’s installed with 96 cell MK-41 VLS, 1 MK-45 main gun, Phalanx CIWS and 2 triple barrel torpedoes. It also carries hangars for 2 MH-60 helicopters for ASW/SAR missions.
<br/><br/>
I think the 4 examples show that the Soviet system is bulkier. Similarly sized cruisers like Slava class does not carry anywhere near the firepower of Arleigh Burke class or KDX-3. The Cold launched S-300F has many advantages over hot launched MK-41 VLS, but also takes up more space and has less flexibility. The combined nuclear/gas turbine and steam turbine option on Soviet cruisers are likely to take up more space than the COGAG arrangements on Arleigh Burke class. Most of the electronics on older Soviet cruisers are heavier. The most visible proof of that can be seen in the FCR for S-300F, which takes up much more space than SPY-1D.
<br/><br/>
So I think it’s quite obvious that PLAN will go for something similar to KDX-3 than Kirov class. Type 055 should be a much stealthier design than that, since newer AAW destroyers like Type 045 have set blueprints on how to design really stealthy warships. As we spoke in previous blog entries, Type 055 will most likely be using 4 QC-280 gas turbines to generate power for an integrated electric propulsion system. It will use the universal VLS already found on 052D, since it will support both the cold launched and hot launched naval missiles in service with PLAN. Type 055 is probably going to hold 112 or 128 cell VLS with no additional launchers for LACM or AShM. In addition, I think it will carry 2 HQ-10 launchers along with 1 or 2 PJ-11 CIWS for point defense. For a large ship like Type 055, PLAN may also have helipad space and hangar space for 2 Z-15 or Z-20 sized helicopters. All of which would call for a ship that’s probably larger than Arleigh Burke class and probably also KDX-3 class. I would estimate it to be around 175 m long and 22 m wide with full load displacement of around 13000 ton.Unknownnoreply@blogger.com9tag:blogger.com,1999:blog-2810814791836407713.post-22356872008622753652016-10-02T06:28:00.001-07:002016-10-02T06:28:20.282-07:00Type 055 program updateWhile reading pop3’s various posts on Type 055, I was struck by how long this project has been planned.
<br/><br/>
As far back as 1968, the Type 055 designation was given to a new large missile destroyer program. By 1970, the701 Institute, Hudong shipyard and NSF commenced work to develop this ship. As one could imagine, China did not have the money or technology needed to develop a large missile destroyer back in those days. By 1981, this program went from an official program to one under research development. Back in the 80s, many PLAN program was dropped due to underfunding and weak technology base. Type 055 program from that time would’ve required CODOG propulsion, ASW helicopter, ECM/ESM system, SAM, sonar countermeasure system, integrated communication system, 3D search radar and rocket assisted torpedo. Those requirements were probably 20 years ahead of its time. If they had built a cruiser, it would’ve been as large as Kirov to fit all of the missiles and electronics that were available at the time. They would not have the propulsion system needed to power such a ship. Even if they did have the appropriate propulsion system, that ship would still not be very capable. That’s why China ended up developing Type 052 destroyer.
<br/><br/>
The most recent reincarnation of Type 055 came about in December of 2009. The project calls for 10k+ ton cruiser with high speed, long endurance, long self-sufficiency and excellent global navigation. It would be a stealthy design with lo acoustic, radar, infrared and electromagnetic signature. It will need to be survivable by itself and be able to lead a fleet. It must have early warning defense system as well as long, medium and close range hard+soft kill weapons. So many requirements were included in the Type 055 design that an initial design was estimated to be over 20,000 ton in displacement. A lot of work was put in to reduce redundancies and complexities in order to better utilize space. For example, the new universal VLS system supports 4 different types of missiles from 4 different firms. Each firm has their own control system, so all of this need to be integrated into one system. In addition, Type 055 will use integrated electric propulsion system, which has smaller space requirements, lower noise level and better fuel economy than previous power generation system. Pop3 estimated the cost of each Type 055, excluding missiles, to be about 6 billion RMB ($900 million). I think that’s reasonable since it’s comparable to what South Korea paid for KDX-3 and quite a bit less than what Japan paid for Atago class. While Type 055 may turn out to be better (or at least more powerful) than those 2 classes of ships, I have a hard time making that prediction at this stage.
<br/><br/>
Type 055 will be China’s first major large surface combatant series since Type 052 series. On SDF, Jeff Head start a thread on <a href=”https://www.sinodefenceforum.com/plan-type-052-destroyer-historical-analysis.t8020/” >052 Historical analysis</a> and put some great thoughts on the history of this program. The overall dimension and propulsion of the type 052 platform did not change too much from Type 052 to Type 052D, but the firepower increased exponentially to become a truly capable multi-role destroyer. Now that Type 052D has been packed in with the most recent Type 346A MFR, 64 cell universal VLS, HQ-10 and PJ-38 main gun, it is probably at the limit of what the Type 052 hull could fill. PLAN is developing Type 055 to be a blue water large surface combatant that can defend itself against many different threats. Type 055 will also probably go through different iteration until reaching the limit of what the initial dimension and propulsion system could support. Comparing to the development of Type 052, Type 055 contains much fewer risks, since most of the weapons (universal VLS, Type 346A radar, HQ-10 and PJ-11 CIWS, YJ-18A AShM and PJ-38 main gun) have already been tested out on Type 052D and Type 054A+. Using relatively mature weapon and radar systems would significantly reduce this type of delays to commissioning of the ship. The 701 Institute has also built a full sized land based simulator of Type 055, which will allow training programs to start before the first unit is launched. Such a real world model would also identify any unexpected results in signature profile and any electronic interference. All of this would reduce the amount of troubleshooting when the first Type 055 gets launched. The Type 052 program never had this kind of luxury, since PLAN was dealing with integrating imported subsystems from different countries at the same time a new hull with new propulsion system was getting tested. No. 113 also uses different propulsion than No. 112 since arms embargo went into affect by then. All of this added a lot of delays to the Type 052 program. I think it’s really interesting to see how much things have changed in 25 years.
Unknownnoreply@blogger.com8tag:blogger.com,1999:blog-2810814791836407713.post-78297029539940275232016-10-02T06:27:00.001-07:002016-10-02T06:27:40.278-07:00PLAN modernization philosophyMost recently, I have been reading writings from pop3, a good source for PLAN, on the upcoming Type 055 cruiser. At the same, I have also been reading and discussing the issue of India’s purchase of Rafael fighter jet. While reading pop3’s thoughts on PLAN development leading up to Type 055, it made me really reflect on PLAN’s philosophy in its drive to modernization.
<br/><br/>
When the news of India’s purchase of Rafael came out, I was quite surprised by how much money they are paying for just 36 Rafael. Of course, India’s leaders were eager to point out they had haggled down price from over $13 billion to over $8 billion. That claim would ignore that the original MRCA rfp was to purchase 126 fighter jets for $8 billion. Even so, it was quite shocking that when they finally settled on direct purchase of 36 Rafael, the average total cost came out to be well over $200 million. If they had actually gotten all ToT and local production from Dassault as they had originally wanted, the cost would undoubtedly have been even higher. If we ignore the service, support, missiles and spare cost of this deal, the fly away cost + “India modification work” would still come out to $160 million per aircraft. I think that would be higher than the fly away cost of F-35, J-20 and probably PAK-FA. For an air force that has continually complained about lack of available squadrons, it seems very curious that price was not a bigger factor in its MRCA competition. To be fair, India is not the only country in the world that ends up paying premium for the weapon system that best fit its performance criteria.
<br/><br/>
I think that most people would agree PLAN has done a really good job of modernization up to this point. They have managed to do so with little access to Western exporters and relatively weak technology base (at least back in the 90s). At the same time, PLAN also had very limited funding for much of 80s and 90s. The question is what I have they done right to get to this point. It certainly helps that they have a productive domestic shipbuilding industry and low cost manufacturing base. South Korea and Japan have also been able to build very powerful ships at reasonable cost by leveraging their competitive shipbuilding industry. However, they both had access to all the major exporters, which China does not have. So what else allows China to modernize so quickly?
<br/><br/>
I think the first part is to look at the practical nature of its naval acquisitions. I want to focus on Type 054/054A program in this example. I read that France sold data of La Fayette frigate to China at the same time it had sold the ships to Taiwan. That certainly sped up their development of hull of Type 054, but I think it also showed they were very practical. While La Fayette is a modern frigate design with advanced signature reduction technology, it does have drawbacks in the role of ASW escort. It uses CODAD propulsion that is quite underpowered and noisy (compared to something using COGAG propulsion like OHP class) for ASW operations. Type 054 and 054A have the same shortcomings. Even so, PLAN recognized that it had access to all the components (including the diesel engines) needed to serially produce a much better frigate than Jiangwei class. There was no reason to wait on a perfect frigate for its requirements. The interesting part is that only 2 Type 054 class frigates were built before they moved onto Type 054A. Even after they had built Type 054, they built 2 more Jiangwei class frigates. At the time they built Type 054, most of the subsystems for Type 054A was not ready. The development of Type 382 Sea Eagle radar (looks like Top Plate) completed in 2002. The development of Type 366 OTH radar (Chinese version of Mineral-ME) completed in 2004. The AJK-16 weapon system (which fires HQ-16 missiles) only started land based testing in 2004. The actual testing on sea came after that. The Yu-8 rocket assisted torpedo completed testing in 2006. So none of these subsystems were ready when Type 054 was laid down. Instead, Type 054 was fitted with the AJK-02 weapon system (HQ-7) and Type 360 search radar. Looking at the firepower of Type 054 vs the most recent Jiangwei units, I would say Type 054 is only slightly more powerful than those Jiangwei. Type 054 would be close to twice as expensive as Jiangwei, but PLAN decided it was important to build and test out this new hull design before adding the new subsystems. When Type 054A was being designed, Type 701 Institute could focus on just integrating the new weapon system onto the same hull as Type 054. Since that point, Type 054A has become the workhorse of PLAN even as newer technology and weapon system has become available. I think they found it more important to mass-produce a good enough design since their frigates have been modernized cheaply and quickly this way. Each 054A probably costs around $250 million, which is very cheap. They can now wait for available technology to catch up to design requirements of Type 054B, since all of the older Type 053 frigates have already been replaced.
<br/><br/>
Another interesting element is China’s goal of not utilizing imports for mass production. Back when Type 052 project first started, China simply did have the technology needed to build what PLAN wanted. They ended up importing various parts from various countries, but were dealt a reality check when military embargo was put in place after the June 4th student crackdown. All of that caused delays in the development and production of the 2 Type 052s. I think Type 052 was way ahead of its time in terms of the technology employed, but PLAN simply could not afford to build more Type 052 until their military industrial complex caught up. Once that happened, they were still very cautious in building 2 Type 052B, 2 Type 052C and 2 Type 051C before the mass production of Type 052C happened. They did not want to rely on importing Ukrainian gas turbines, so waited until domestic version of DA-80 was ready for production. They were willing to test out new technology like Type 346 radar and AJK-03 VLS on 2 ships, but were not willing to mass-produce more Type 052Cs until the technology was more mature. Since QC-280 became available, Type 052C and 052D production has been continuous. It does not matter to PLAN if the subsystem is foreign designed or inspired as long as domestic firms can produce them cheaply. Due to cost and lack of import options, PLAN was driven to rely on domestic production for all of the new naval surface combatants. One could say that PLAN modernization has completed now that probably 2/3 of its ships have been replaced with modern designs.
Unknownnoreply@blogger.com22tag:blogger.com,1999:blog-2810814791836407713.post-45969109258767960102016-09-12T17:20:00.001-07:002016-09-12T17:20:54.750-07:00Thoughts on the so called H-20 bomberAfter the development of Y-20 and J-20, the next military major aviation project in China is the rumoured H-20 bomber project. Although we do not know the exact designation, PLAAF’s top officer, General Ma Xiatian, recently announced that China is developing a next generation, long-range bomber, which will be seen in near future. Just from his statement, I think it’s fair to say that the project is in advanced development. Since H-20 is a strategic platform, it would have even higher level of secrecy than J-20. Speculations over this next generation bomber project have already replaced J-20 and the fate of J-31 as the hottest subject on Chinese military boards. I remember back in 2009, a similar statement was said about J-20. The PLAAF officer said that the next generation fighter jet is expected to go into service in 8 to 10 years. We saw pictures of the first prototype less than 2 years later. And now, it appears that J-20 project will go into service in 2017, just 8 years after the original statement. From this, we can see that when a top level PLAAF officer makes a statement about a major strategic platform, it will usually be quite on the mark. From that, I would expect the first prototype to be built sometimes next year and make maiden flight in 2018. That also seems to be when our friend Huitong thinks the maiden flight will be.
<br/><br/>
From what I read on Huitong’s blog and other sources, it seems like 603 Institute/XAC will be the primary developer of this project. That would make a lot of sense given their work in the JH-7 series of fighter-bomber and H-6 series of bombers. With the completion of the primary development work for the Y-20 project, additional engineering resources are now available to really speed up H-20 development. Unfortunately, the “wall climbing” community isn’t as active in Xi’an as it is in Chengdu, so we might not see photos coming out as soon as in J-20. At the same time, H-20 should be considered a more classified project than J-20, so we would likely have fewer pictures and info on it than J-20. One only has to think about the classified nature of F-117 and B-2 compared to F-22/35 to imagine how secretive H-20 should be.
<br/><br/>
The next part is to look at what China has for attack and bomber project right now. China has operated H-6 bombers since first importing Tu-16 technology from Russia back in the 60s. Over time, XAC improved on the avionics and missiles carried by H-6 to develop various improved models fro PLAAF and PLANAF. When they got access to Spey engine, they also experimented installing it H-6 (but did not adopt it). More recently, XAC worked on the H-6K project, which made its maiden flight in 2007. H-6K was delayed due to engine issues, but resumed production in 2009 after they got D-30KP2 from Russia. Since they purchased large quantity of D-30, they have been able to produce about 1 regiment of H-6K (about 20 bombers) every 2 years. H-6K is a large improvement over earlier H-6 in range with payload. It can carry 6 KD-20s for long-range strike and have participated in numerous exercises. Most recently, it crossed Baishi channel in an exercise with Su-30s, early warning aircraft and refueling tankers. Even with all of this improvement, H-6K still pales in comparison to Tu-95MS and B-52 in range and payload. With the KD-20 missiles, H-6K can serve the role of missile carriers/bomb truck, but is not capable of longer ranged missions. Back in 2005, there were speculations that China was interested in Tu-22M3 backfire bombers, but that never happened. I think China was interested in bombers of that quality, but not used frames incapable of launching Chinese missiles. There were speculations a while back that China would develop a domestic version of backfire called H-18. However, that turned out to be a hoax. At this point, I think China would be interested in Tu-160 bomber, but Russia is probably not willing to sell such a strategic platform. For the past 5 years, we have seen induction of 3 H-6K regiments and many new types of missiles and bombers. H-6Ks have been installed with numerous types of electronics. I think the H-6K program serves as a good test bed for missiles and avionics that PLAAF would like to install on the next generation bomber. Once H-20 does join service, H-6K could still serve a role of bomb truck and EW aircraft.
<br/><br/>
So what would a H-20 bomber look like? The PLA’s definition of a long-range strategic bomber is a minimum range of 8,000 km (5,000 miles) without refueling and the capacity to carry a payload of more than 10 tons of air-to-ground ammunition. Considering that PLAAF it looking for such a bomber and has chosen to not develop its version of backfire, they are clearly looking for something more advanced than Tu-22M3. It would be a tremendous leap to go from H-6K to Tu-160 or B-1 bomber. Huitong’s blog indicated that China is looking for an even more advanced flying wing design akin to the B-2 bomber. If XAC is looking to develop something close to the capability of B-2, the leap from H-6K would be larger than any project in the history of Chinese military aviation (with only J-10 project as comparable). Fortunately, China already has tested out many elements needed for a modern bomber. First of all, it finally has a modern turbofan engine needed for such a bomber. B-1 bomber uses F-101, which was developed into F-110 used on F-15/16s. B-2 bomber uses F-118, which is a non-afterburning turbofan engine developed from F-110. So depending on whether XAC is looking for a supersonic bomber, they could either go with a variant of WS-10 with or without afterburner. In the future, they could also try a version of WS-15. In terms of sensors, they have already tested out various ground scanning radar, AESA radar, EW suites, FLIR/EO turret and laser designator on J-20 and H-6K. I certainly think they can develop some very capable for H-20. In terms of weaponry, stand off missiles, anti-radiation missiles and precision guided missiles have already been developed and in service with various attack aircraft. The big question is whether or not they have the stealth technology, advanced light materials, battlefield surveillance technology and FBW software needed to have a modern long-range LO signature bomber. The 601 Institute and Hongdu have been testing some of the technology since 2013 with the Sharp Sword UCAV, so it can share the data from testing with XAC. However, in order to scale that data up to something the size of a strategic bomber with 4 large turbofan engines, XAC has a lot of work ahead.
Unknownnoreply@blogger.com38tag:blogger.com,1999:blog-2810814791836407713.post-80634382839235431032016-09-10T06:57:00.003-07:002016-09-10T06:57:58.596-07:00J-31 UpdatesMost recently, the first LRIP batch of J-20 appears to be handed over to FTTC to start the processing of getting inducted into PLAAF later this year or early next. While J-20 has progressed very smoothly up to this point, J-31 appears to have run into a major roadblock.
<br/><br/>
As readers may know, the first J-31 demonstrator came out a couple of years ago to great fanfare. At the time, it was thought to be a SAC funded private project that was also getting some PLAAF funding. Many people, including me, thought that was the first step to getting picked up by PLAAF and/or PLANAF. As it happened, we never saw a second version or a real prototype of J-31 despite many rumours and interesting models in air shows. There were even some rumours earlier this year that a second version of J-31 was about to come out that would be a lot further along toward a production model.
<br/><br/>
Most recently, one of the insiders on Chinese forums said that J-31 has not been picked up by PLAAF or PLANAF. At the same time, a more official source said that J-31 is for export. And we know that J-31 will again be brought to display in the 2016 Zhuhai air show. From all of this, it seems that SAC is working hard to attract foreign funding to continue this project. At least as of now, neither the air force nor the navy has interest in this project. Now, I was always under the impression that PLAAF only had interest in one 5th generation fighter jet prior to J-31 demonstrator came out. After that, I thought J-31 might serve as the low end of PLAAF’s future combat force instead of an upgraded J-10 variant. If PLAAF rejected J-31, that could either mean it has no interest in funding a 2nd type of 5th generation aircraft or that J-31 is simple not up to par. If the reason is latter, that could either mean J-31 design is technologically up to PLAAF expectations (in terms of stealth, radar or flight performance) or cost to performance below expectations or certain components simply not ready (like the next generation engine). While PLAAF questions are harder to answer, we do know for sure that PLANAF will need a next generation naval aircraft to replace J-15s. However, they rejected J-31 even though SAC has some real naval aircraft experience in developing and building J-15. So what do I make all of this?
<br/><br/>
I think PLAAF will not be ordering that many J-20 over its lifetime, because it is envisions as a high-end aircraft (ala F-22). They definitely need a cheaper and less capable fighter jet that can at least be competitive against F-35s. I don’t think the extremely unstealthy J-11 series or the light and less powerful J-10 series can be the answer to that. Sometimes in the next decade, PLAAF will have the desire for a true lower end 5th generation aircraft. In the past, PLAAF eventually did pick aircraft types that it had originally rejected like JH-7 and K-8 (possibly even L-15). In the case of latter, Hongdu managed to persuade foreign investment into the project. It was only after suitable engines became available that PLAAF decided to pick up K-8 as JL-8. I think that is the road J-31 could go. If it can attract enough foreign funding to continue, then domestic engine options should become available sometimes next decade. At that time, PLAAF could certainly choose to order it. The other question is whether or not PLAAF is willing to have Chengdu produce 2 different 5th generation types. Up until now, PLAAF has preferred to split its projects between Chengdu and Shenyang. Shenyang got the heavy fighter and Chengdu the light fighter. Chengdu won the 5th generation contest with its heavy design to the surprise of many. With J-20’s rapid progress, it hardened my view that Chengdu is far more capable of developing new fighter jet series than Shenyang. With the failure of J-31, I do question whether or not Shenyang is even capable of developing a new fighter jet that appeals to PLAAF. We know it can create new variants of flankers, but that’s far from developing a new aircraft. On the other hand, Chengdu has a lot of work with J-20 series, J-10 series and numerous UAVs. While J-20 was in serious development, the progress of J-10B/C was quite slow due to the shift in engineering resources. When J-20 does go in production in a couple of years, could Chengdu have enough resource again for a new fighter series as well as continued support and upgrades for J-20 and J-10? I certainly have doubts about that. I do think that it is still more likely Shenyang will be producing a 5th generation aircraft type for PLAAF in the future.
<br/><br/>
As for PLANAF, the fight is now between a navalized version of J-20 from CAC or something new from SAC. Shenyang won the first round, because PLAN liked the range and payload of flankers. For the next generation, SAC has to start from scratch, while CAC already has a functioning aircraft. Since J-31 has already been rejected, SAC has to come up with something better than that to win over PLAN. J-15 is likely to be in production for at least the next aircraft carrier CV-17. After that, the next generation aircraft carriers of PLAN will likely to be larger than CV-16/17. They would be CATOBAR carriers that can launch fixed wing AEW asset, fully loaded fighter jet and long-range fighter-bombers. Even though J-15 has only joined service recently, PLANAF will soon be deciding between SAC and CAC on the next generation fighter jet. At this point, it seems more likely that a naval version of J-20 or a naval fighter-bomber based on J-20 would get picked.
<br/><br/>
So all of this would indicate SAC needs to do something to impress on the decision makers. Most of their projects right now are some flanker variations. We saw the sharp sword demonstrator a while back, but CAC has shown more UAV designs. It will be interesting to see how SAC can move on from the J-11 series.
<br/><br/>
Finally, I hear the rumour that the “20” series of aircraft will be the start in Zhuhai airshow this year. I can certainly see Y-20 and Z-20 make appearances in the air show and fly around. However, I do not think J-20 will participate this year. J-31 will appear and try to attract more funding. H-20 is the other project that has attracted a lot of attention from PLA watchers. At this point, we probably won’t see much about it until after it makes a maiden flight. With the size of J-20, I think it can be used to develop a next generation fighter-bomber.
Unknownnoreply@blogger.com7tag:blogger.com,1999:blog-2810814791836407713.post-49230903136684797842016-05-11T23:18:00.003-07:002016-05-11T23:18:47.970-07:00Air force comparisonsIn the past, I have often seen or tried to stop discussions over what I call vs battles. Military fans universally love to debate whether one aircraft is better than another one. There are many good reasons for that obviously. For PLAAF, if w can determine that J-10 is stronger in air combat than flankers and are up to part or close to up to part with the teens and eurocanards, then China can deal with all of the surrounding threats. More contemporarily, the argument of J-20 vs F-35 vs F-22 vs PAK-FA is popular in establishing China’s future options against US and its allies.
<br/><br/>
In general, I have not enjoyed to get involved with such discussions, because I don’t think they yield good discussions or give good indications of how real world combat scenarios will turn out. Recently, there were some discussions regarding the results of PLAAF’s exercises with Thailand. It was mentioned on Chinese forums that PLAAF sent flankers. The flankers apparently won dogfights but lost on BVR engagements. This led to numerous people asking about which type of flankers were sent. If earlier versions of flankers like Su-27 or J-11 were sent, then it would be okay if they did not win the BVR exchanges. I immediately thought about the exercise they had several years ago with Turkey. In that exercise, China sent some earlier flankers and Turkey used F-4s (or at least that’s what we presume since F-16s were not involved). I presume China sends earlier flankers because flight characteristics and avionics of these fighter jets are well known, whereas J-10 and even J-11B numbers are very well guarded state secrets. At the time of exercise, it was rumoured on Chinese forums that the flankers were crushed in the exercise and that the DACT were designed in a way that put Chinese jets in very disadvantageous positions. While none of the rumoured results can be confirmed, I think there are a lot of good reasons why PLAAF would take this approach. Back in 2005, there were a lot of excitements amongst Indian defense followers because IAF fighter jets had done well against F-15Cs in DACT with USAF. Even though it was reported that USAF fighter jets were operating under very challenging conditions on what they could or could not do, many IAF fans were excited to report that Su-30K and Mig-21 Bisons had beaten the F-15Cs.
<br/><br/>
With that in mind, I think we should consider why PLAAF participates in these exercises and what it has to gain by setting certain DACT scenarios. For the former, I think that PLAAF recognizes it does not do enough training with other air forces, so these exercises are valuable in learning about flying styles and tactics of other air forces. In the exercises with Turkey, I think PLAAF purposefully set challenging conditions so it can see how NATO air forces operate with numerical advantages, EW advantages and BVR advantages. So even if Turkey does not showcase F-16s, PLAAF had a lot to gain by participating in them. I’m not saying that Su-27s are significantly better than later F-4s or that PLAAF pilots are at the same level of NATO pilots. Those are things I simply don’t have enough data on. Compared to NATO, PLAAF is still at a very early stage in DACT exercises. PLAAF Su-27s and early J-11As have probably participated in most number of DACT engagements in China’s own version of Red/Blue flag exercises. Early on, they were consistently defeated by J-7s even though they are much superior aircraft. Flankers won later when PLAAF developed better tactics for them. So when PLAAF encounters a more experienced air force like Turkey, it would have a lot of learning to do. PLAAF recognizes that in many realistic war scenarios, its fighters could be facing massive disadvantages in the operational environment. From that, it would be logical to do various DACT under disadvantageous conditions even if PLAAF pilots have to suffer some humble pie. I can’t speak for the results of Pakistan or Thailand, but I think without knowing PLAAF’s intentions and the DACT scenarios, results of these exercises are not too meaningful even if we know the aircraft types. I do read from the big shrimps on Chinese bbs that PAF pilots are better than PLAAF pilots. If that is still the case, then it makes even more sense for PLAAF to train more regularly with PAF.
<br/><br/>
J-10A and J-11 have made a good pairing for PLAAF for the past 10 years and would hold up against current front line fighter jet in surrounding countries like Su-27/30, F-15J, F-16C/D and Mig-29s. J-10B/C and J-16 will be comparable or a little inferior to the latest eurocanards, Su-35s, F-15K/SG and F-18E/F. On paper, they have the latest avionics (including AESA radar), a full range of multirole capability and improved range compare to their base models. Even with higher thrust engines, will they still be capable of having the same flight performance as earlier models when we considered the increased weight from all these changes? As for J-20, I think it has many advantages over PAK-FA, but less so against F-22/35, especially in the environment that they are likely to operate in. J-31 seems like a good second project, but we are still waiting to see what the second prototype looks like. It could turn out to be a genuine lower cost 5th generation fighter jet or one that’s significantly more stealthy than eurocanards and F-18E/F, but also lacking the full aspect stealth, flight performance and networking centric capability of a true 5th generation aircraft. Until J-20 gets mature and installed with WS15, it will have similar concerns. That’s how I would rate them.
Unknownnoreply@blogger.com40tag:blogger.com,1999:blog-2810814791836407713.post-36706380004762222032016-03-25T15:13:00.002-07:002016-03-25T15:13:26.107-07:00Carrier Fleet and Strategic transportThis entry will focus on two of the largest strategic projects that China is currently working on: Carrier fleet and strategic transport (Y-20). <br/>
<br/>
For the former, there has been increasing number of photos from Dalian shipyard showing the first domestic carrier taking form. This carrier, commonly referred as 001A, is expected to be very similar to Type 001 CV-16. Both carriers are conventionally powered STOBAR carrier with an air wing consistent of J-15s, Z-18s and Z-9s. There have been many photos of production J-15s (Number 100 to 114) operating off CV-16 since the start of the year. It seems like the standard weapon load for air defense version of J-15s is 2 MRAAMs + 2 SRAAMs. Ground attack variants could carry 2 YJ-83s + 2 SRAAMs. More importantly, the latest photos show several J-15s on flight deck at the same time with many crew members doing standard carrier operation duties. There are pictures show 5 or 6 J-15s parked with their wings folded, a tug dragging helicopter around, elevator carrying plane to flight deck and multiple J-15s about to take off. We have even seen photos from late afternoon or early evening showing flight deck operation with lights on. While the last part does not conclude they have started doing take off and landing in the evenings, it does indicate that part maybe coming sooner than many people would have guessed a year ago. One of my fellow SDF moderators even commented on how the CV-16 flight decks show more activity than any of the photos from Soviet Union ones. The next step would be more integrated exercises with other ships of a carrier fleet.<br/>
<br/>
For the latter, recent report has come out that the development of Y-20 may complete this year leading to the start of mass production sometimes this year. So far, there have been 5 flying prototypes (No. 781, 783, 785, 788 and 789) along with unknown static prototypes. Even though Y-20 made its first flight in 2013, strategic transport do not need to conduct flight testing for as long as fighter jet projects. At the same time, WS-18 achieved design certification last year, so it should be ready for mass production this year. It’s possible that the earlier Y-20s may still use D-30KP2, but they have bought over 200 D-30s in the past. Even accounting for H-6 usage, the remaining D-30s should allow time for production WS-18s to mature. As I’ve discussed before, Y-20 will not only be used for transport purposes, but also on tankers, AWACs, special mission aircraft and ABL platform. While the requirements of these aircraft types can differ, they also all have common requirements of long range, long endurance, high payload, and good short field performance from conventional and unpaved runways. We know that Y-20 probably will be required to carry something the size of ZTZ-99. That would lead to payload requirement of over 60 tons. We don’t have any performance data outside of that other than the belief that it will similar to comparable transports. We know that the wings and fuselage of Y-20 will have to be optimized to balance performance in takeoff, cargo space, endurance and range based on what PLAAF thinks the future requirements of Y-20 are. That requirement maybe different from what the Soviet Union envisioned for IL-76 or US envisioned for C-17. For example, how would a transport like IL-76 originally developed to carry at most 40 ton in payload be able to carry larger payload efficiently now that its payload has been increased with the new PS-90A engines. That’s one of the major advantages to developing one’s own strategic transport. Compared to IL-76 (and the upgraded IL-476), Y-20 should eventually use more efficient engines (WS-20), more modern flight control system and avionics, more advanced material (vs what was available in 70s) and more efficient wing for China’s missions. With newer construction techniques available that China has learnt from working with Airbus and Boeing, Y-20 could end up with a really modern production line. Once production for Y-20 ramps up, we will be able to see how much fruit this project will reap from the RnD in COMAC projects like C919. Unknownnoreply@blogger.com11tag:blogger.com,1999:blog-2810814791836407713.post-22135678385886039062016-03-05T08:38:00.002-08:002016-03-05T08:38:36.820-08:00052C radar + Aeroengine developmentSince the Lunar New Year break started, not much significant news have happened, but there were a couple of story lines in the past month that caught my attention.<br/>
<br/>
The first one is this <a href="http://www.weibo.com/ttarticle/p/show?id=2309403947493393103923">story on weibo</a> from someone who said to have participated in the initial part of Type 346 radar development (for 052C) before immigrating to Canada in the late 90s. There has been a lot of criticism on this article regarding author's decision to leave China and also on whether or not he actually worked on the project (or just made this all up). Looking through some of the online discussions on this like <a href="http://www.hobbyshanghai.com.cn/thread-154113-1-1.html">this thread on hsh</a>, I'm still not convinced on whether or not this is authentic or something this author wrote from other sources he read online. Even so, I think it's an article that's well worth reading. The human part of the story rings true to people who are far more involved with the inner working of Chinese navy than I am. Certainly during the earlier days, many talented people left China because they were simply not appreciated or adequately compensated for the work they were doing.<br/>
<br/>
Aside from that, I think it's quite interesting to consider how PLA awarded R&D funding to various institutions. Outside of the process, very few people know how competitive some of these PLA contracts are. This article allows us to see the geopolitical, political and relational angles that affect each contract award. It makes sense for each of the competing firm to try their utmost to win R&D grants and funding regardless of whether or not their proposal is the best. Certainly, having the right person to lobby for your proposal can go a long way toward covering up deficiencies versus opposing proposals. In the end of the process, I think it almost seems like Chinese navy picked 14th Institute proposal out of luck due to an expected geopolitical event. That decision certainly seems to have yielded good results since the 14th Institute has since produced many quality AESA radar for both the air force and the navy. I think the numerous "big shrimps" on Chinese forums have also corroborated the political influence and connections that sometimes lead to picking the less optimal option. On the plus side, it also illustrated how fiercely competitive these firms have to go to pick up funding for their projects. This higher level of competition inside China (that we don't really read about) helps push projects forward in ways that don't seem to happen in India.<br/>
<br/>
At the same time, a lot of aeroengine related news came out. It was reported that WS-10B achieving design certification, WS-10 achieved production certification and WS-15 was going into the process of achieving design certification. Broadly speaking, there are 4 major stages in China with respect to developing and certifying a new engine.<br/>
<ul>
<li>
The first phase is the test/experimental stage prior to the initial flight. This involves all of the ground based testing on the parts of engine and as a whole. It goes through a series of test on the test vehicle and its parts to make sure that it's ready to go through flight testing.
</li>
<li>
The second phase is the research test flight stage. Before going into the process of certification test flights, the test vehicle is flown under realistic flight scenarios and flight envelope. The main tasks include preliminary assessment of engine flight performance, features, reliability, maintainability, testability and supportability. Flight tests could be carried out in a flight engine test bed or on an intended aircraft. At the conclusion of test flights, the technological maturity level should reach level 7. In WS-15 testing, it had to complete 60 hours of endurance testing on flight testbed before completing this phase. So at this point, the engine is demonstrated to have at least 60 hours of service life prior to overhauling.
</li>
<li>
The third phase is the design certification stage. Before low rate initial production, it must go through a series of ground testing of the engine, its systems and the individual parts. It must also go through with high altitude testing and flight certification. Most importantly, it has to go through the initial overhaul long endurance testing on testbed. For WS-10 and WS-10B, they had to complete a 300 hour endurance testing to complete this stage. Under testing of full flight envelope, these tests will determine the reliability, maintainability, testability, safety and service life. At its conclusion, the technological maturity level should reach level 8.
</li>
<li>
The fourth phase is the production certification stage. Before mass production of an engine, it must be deployed in smaller number of aircraft (with active service aircraft) for test usage in order to become mature. It must go through with full service life endurance testing on test bed. It must complete comprehensive verification of engine performance and reliability under mass production quality. Mass produced version of WS-10 must complete 1000 hour of endurance before completing this stage, the initial overhaul time is at least 1000 hours. At its conclusion, the technological maturity level should reach level 9.
</li>
</ul>
<br/>
From the above, one can get a sense of where each of the engine is at. WS-10 has completed production certification, so it is now quite reliable (1000 hours MTBO) and deployed on most of the J-11Bs. As reported in numerous places, this version of WS-10 achieves a maximum thrust of 12.5 ton with afterburners. WS-10B has now completed design certification (at least 300 hours MTBO) and is deployed on some flankers and a couple of J-10Bs. According to numerous reports, it achieves maximum thrust of 14 ton (12% more than WS-10) with afterburners and features a digital control system (FADEC). Since both flanker and J-10B already has more reliable but less powerful engine in service, WS-10B will probably be deployed in smaller numbers until it becomes more reliable. WS-10B should have greater thrust than even AL-31FN series 3 (14 ton to 13.5 ton), so it would be the better choice once flight testing on J-10B is completed. Once we see a full batch of J-10B installed with WS-10B as opposed to AL-31FN, then WS-10B is probably in mass production and not far from production certification. The next improvement to WS-10 includes adding a new thrust vectoring control and achieving higher maximum thrust. That variant of WS-10 is probably under design certification tests right now. There is also a variant of WS-10 being developed for naval fighter jet J-15, which should become certified soon.<br/>
<br/>
We also got the news that WS-13E may have achieved design certification and will begin production this year. It is said to be an improved version of WS-13 and achieves close to 9 ton in thrust (8.7 ton on original WS-13). That's compared to 8.3 ton on RD-93 and 9.3 ton on RD-93MA. This engine could be used on JF-17 or FC-31 or Lijian UCAV. Since this is still very early in its production cycle, it would be interesting to see where it will first be deployed on.Unknownnoreply@blogger.com8tag:blogger.com,1999:blog-2810814791836407713.post-25347474438265539582016-01-16T04:32:00.001-08:002016-01-16T04:32:44.691-08:00J-20 and geopolitical implications.The J-20 project has made some significant progress in the past 2 years with the roll out of prototypes 2011 to 2017 to accelerate the flights testing and development of the J-20 aircraft. With the roll out of 2101, what appears to J-20’s first LRIP aircraft, it’s possible that the first batch of J-20s will get delivered to FTTC this year to start the process of expanding flight envelope, testing/evaluating new weapon systems, developing new training procedures and combat tactics for a new aircraft. If FTTC evaluation proceeds well, J-20 may be certified and start entering into service next year. It looks like the project is proceeding a couple of years faster than the original expectations. For this entry, I want to look at how the progress of J-20 vs progress of other fighter jet projects affects regional balance of air power.<br/>
<br/>
To start off, the most obvious threat to PLAAF comes from the vast number of F-35s that will be deployed in the APAC region by America and its allies. Due to defense cutbacks by many Western countries, key American allies in APAC region should not have to wait too long to get their F-35s. If J-20 enters service in the next 2 years, it will enter service extremely underpowered since WS-15 is not yet ready. As a result, I think the initial J-20s will have to carry limited fuel and payload in order to achieve desired flight performance. Until WS-15 does become certified with J-20 sometimes next decade, there are certain missions involving longer range and greater payload that J-20 just cannot perform. USAF and USN’s will have overwhelming qualitative and quantitative advantage in the region against PLAAF in the short term. Even after J-20 enters service in larger numbers later with WS-15, I think USAF and USN’s F-35s will still have both qualitative and quantitative advantage in the region. J-20 probably will have certain advantages over F-35 in flight performance, power and payload, but will definitely be at large disadvantage in stealth, sensors, weapon system and the ability to operate in a network centric environment. Reading Chinese sources, I have often gotten the impression that PLAAF regards F-35 as its biggest threat (even more than F-22) due to F-35’s technical and numerical advantage over what China might field. I don’t think anything from the past couple of years have really changed that.<br/>
<br/>
I think a more interesting case is to compare J-20 to the PAK-FA project. I have often compared the 2 projects in the recent years, because they have started about the same time and went with similar platforms that seem to be natural evolution from flankers. In J-20, China seemed to put more emphasis on overall stealth and range. The Russians seemed to put greater emphasis on maneuverability. From the beginning, I had always thought the PAK-FA development would finish first due to Russia’s previous R&D into 5th generation fighter jet, the earlier first flight of PAK-FA and original pronouncement of 2016 IOC. As mentioned several times before, this has been turned upside down in the last 2 years as PAK-FA have been plagued with problems whereas J-20 is proceeding without any obvious setbacks. Without comparing the capabilities of the 2 aircraft, it seems more likely now for j-20 to join service before PAK-FA does. Another part to look at is the new engine options for the two aircraft, since both will first enter service with underpowered AL-31 or WS-10 variants. PAK-FA will later use izdeliye 30, whereas J-20 will use WS-15. The former is expected to start flight trials in 2017 and join service around 2020 and the latter has similar timelines. With China’s previous problems in mass production of a new turbofan engine, WS-15 entry may drag on a couple of years longer, but entry into service for both engines are pretty close. That means it will probably take early 2020s before the appropriately powered version of both J-20 and PAK-FA go into service. Looking at the progress of the 2 programs at the current time, it seems like J-20 is far more likely to join service on time since most of its subsystems (other than engine) are ready, whereas PAK-FA has been delayed in both its flight testing (by fire on the 5th prototype) and subsystems (like radar). So, China will get operational J-20s before Russia does with PAK-FA. Although the 2 countries are currently friendly, China considered Russia to be its greatest enemy as recently as late 80s. I think it’s quite important for China to not rely on Russia weaponry for security reasons. It’s important to note China has been Russia’s student since the 50s. It would be a tremendous boost for Chinese pride to be ahead of Russia in military aviation. The other part of J-20 vs PAK-FA comparison is India’s involvement. India will receive production PAK-FA several years after Russia. India was part of PAK-FA development since the beginning when it proudly pronounced that Russia was only willing to partner with India (rather than China) in its 5th generation fighter jet project. Since then, India has regularly complained about its involvement in the project as PAK-FA falls behind schedule. India also complains about the cost and technical capabilities of PAK-FA. As a whole, it seems like India is not getting the aircraft it wants or the development experience it wants or the timeline it was hoping for. All of this has added up to a nightmare scenario where China will receive a possibly more advanced 5th generation aircraft several years before India does. The best aircraft India can field at that time will be Rafael. It’s also possible that China’s second 5th generation project, J-31, will be in service very soon after PAK-FA goes into service with India. If China exports J-31 to Pakistan after a couple of years, then India will have very few years of advantage over Pakistan in 5th generation fighter jet. So while India originally had hoped for getting PAK-FA several years before China gets J-20, it may now be trapped in a situation of 2 hostile neighbours with 5th generation aircraft. There have not been much mentions of MCA in the past year. Looking at how long LCA has been in development, I can only assume that means MCA is much further away from completion.<br/>
<br/>
The only other next generation development projects are Korea’s KFX project and Japan’s ATD-X/F-3 project. Since both countries only have one recent fighter jet project experience (Korea with T-50 and Japan with F-2), it’s unclear how long the development will take or how capable the aircraft will be. In both cases, I would imagine they would seek for as much American help as they can. These two countries are looking to establish long-term viable domestic military aircraft makers through these projects. However, I don’t think it’s America’s interest to create possible competitors that may take away future exports. In both cases, I think they will probably create semi-stealthy designs that are comparable in performance to the eurocanards. As shown in PAK-FA and J-20 project, creating 5th generation aircraft will all aspect stealth is extremely difficult. America was able to do so, because it had decades of experience in stealth. Looking at Japan’s previous venture, F-2 was over-budget and under delivered in performance. Japan has not worked on any fighter jet programs since. Korea has only developed an advanced trainer in T-50. It seems to be a huge challenge to go from that to 5th generation fighter jet. Both countries are expected to field F-35 when very few APAC countries have 5th generation aircraft. Unless they try to throw away that advantage for the sake of national pride, they seem both well positioned for the future. J-20’s success may push both countries to be more invested in F-35 project, since they cannot afford to wait on their domestic programs.<br/>
<br/>
Overall, I think the progress of J-20 does change the geopolitical calculations in the region. Countries that field PAK-FA like Russia and India are now at a disadvantage. If the J-31 project can move forward quickly in the next 5 years, it could have some real export potentials in countries that had been importing Russian fighter jet. F-35 program is in full production mode, so I don’t think much has changed in countries that will be fielding F-35.
Unknownnoreply@blogger.com6tag:blogger.com,1999:blog-2810814791836407713.post-54437939396157709342015-12-27T18:44:00.000-08:002015-12-27T18:44:19.010-08:002015 Year in ReviewAs the end of 2015 draw near, I’d like to take a look at all the important PLA stories of 2015. There are both numerous air force and naval stories. Compared to previous years, there were more news coming out of air force than navy this year as J-20, J-10, flankers and C-919 project all had significant progress.<br/>
<br/>
The major focus of this past few months have been the progress of J-20 project. After 4 new prototypes came out last year with significant changes from the J-20 demonstrators, there was not much happening this year until September of this year when prototypes No. 2016 came out followed by prototype No. 2017 in November. The latest prototype showed slightly reshaped canopy and a new ejection seat, but is generally the same as the earlier prototypes. With these 2 prototypes, there are rumours of 2 more prototypes No. 2018 and 2019 coming out to speed up the testing phase. That has yet to happen, but we have seen what appears to be the first Low Rate Initial Production J-20 showing up most recently with the appearance of No. 2101. Unlike the prototype ones, it is painted entirely in yellow primers. The prototypes are typically sent to CFTE for flight-testing. If No. 2101 is the first LRIP model, then it will probably get sent with the rest of its batch to FTTC for expanding the flight envelope, testing out usage of new systems, developing combat tactics and training manual for J-20 pilots. The first J-10 squad was also established in FTTC before the 44th regiment received J-10. At the current pace, it’s definitely possible for J-20 to achieve IOC or some level of combat capability by 2017. Compared to PAK-FA, I think J-20 is now actually quite a bit ahead. The only major concern for this program is that WS-15 engine is still several years from entering service, so will be quite underpowered for the first few years. At the current time, J-20 is probably testing with AL-31FN Cep 3 engine (that are used for J-10C). Some of the missiles being developed for weapon bay may not be ready yet, but other programs like PL-10, miniature PGMs should be. Not much seemed to have happened with FC-31 project this year, but it has appeared in numerous air shows. For 2016, I will be watching out to see how many LRIP J-20s come out and the expanded test program for the J-20 prototypes. It will also be interested to see if a second FC-31 prototype comes out next year.<br/>
<br/>
At the same time that J-20 has been moving forward, the production of J-10 series have started to pick up again. J-10B development has in my opinion been delays due to CAC focusing on J-20 project, but production level has been pretty good since 2014. There were about 53 J-10Bs produced in block 1 and they have all joined service. Block 2 production has since started and reached at least in the mid 20s. They are supposedly built to the J-10C standard with AESA radar (instead of PESA like J-10B) and numerous other electronic improvements. We are still unsure of all the regiments that have received J-10B/C, because photos normally have their numbers blurred out. Huitong’s blog currently has listed FTTC, 2nd division, 19th division and 21st division as having J-10B/C regiments. From what I have seen, FTTC received J-10Bs first and the old J-10A 2nd division regiment has been receiving J-10Bs. Also, it’s interesting that we have been seeing numerous J-10Bs (without the J-10C improvements) flying with Taihang engine. So I think it is possible that we will see both J-10B with Taihang and J-10C with AL-31FN Series 3 engine produced next year. Based on the recent production numbers, China probably needs to place another AL-31FN order soon.<br/>
<br/>
China also had some more movements with its larger aircraft programs. It received the second refurbished IL-78s from Ukraine (out of 3 on order) and more of the refurbished IL-76s. We also continue to hear more on development of Y-20 and its engines (WS-18 and WS-20). The development of Y-20 will probably complete by 2017 based on its current progress. As I wrote about many times before, PLAAF has large requirement of Y-20 for transport, tankers and special missions platform. I’m sure the LRIP for Y-20 will begin next year, but it’s hard to say when they would be able to ramp up its production to the point where it no longer needs to import IL-76/78s. At the same time, China unveiled the first C919 airliner this year and also finally completed flight certification of ARJ-21. At this point, it seems like C919 is already a great improvement in almost every aspect over ARJ-21. However, it’s going into the market against an extremely capable A320NEO series and B737 MAX series. It does not seem to have any real advantage over those 2 series and will not enter service earlier. In most of China’s domestic routes, it should be competitive with those 2, so I would expect it to capture a good number of orders once it completes flight certification. The big challenges ahead will be to obtain FAA/EASA certification, achieve export orders, ramping up production and completing all of this with minimal delays. This is a tremendous undertaking, but COMAC would be getting a lot of valuable experiences if it can achieve all of that.<br/>
<br/>
Another area of aviation that China has done well on this year is in the field of UAVs. The CH-3/4 UCAVs have been exported to numerous countries (at least Nigeria, Iraq, Egypt, UAE and Saudi Arabia). It has already been used in conflicts against ISIS and Yemen rebels. China had been displaying numerous miniature (50 kg) PGMs and ground attack missiles in weapon shows along with CH-4 UAVs and these have now been tested in real war action. So from these action, it’s likely that CH-4 will get more export orders in the coming years. The WingLoong series has also achieved export orders with UAE and with PLA. Along with these MQ-1 like UCAV program, China is also developing numerous larger UAVs and UCAVs. Those programs are likely developed just for domestic usage and not marketed for exports. It’s unclear how many of these programs will actually see production.<br/>
<br/>
For the Chinese navy, the major ticket item is its aircraft carrier program. Throughout this year, more and more photos came out from Dalian rumoured to be modules of the first domestic aircraft carriers. At this point, I think most Chinese navy watchers would agree that this is the first domestic carrier (aka Project 001A). Over 2016, one of the main areas to follow would be the progress of this first carrier. Over the past year, the intensity of CV-16 exercises seemed to be picking up. Over this past year, Shenyang AC has been producing more production versions of J-15s. There are at least 15 of them now from 100 to 114 and all of them probably have flown off CV-16. In the most recent exercise, at least 6 of them were shown on deck at the same time and as many as 10 were probably on CV-16 in this exercise. That’s a definite step forward in carrier operations from earlier this year and previous years. On top of having more J-15s on board, having more types of combat aircraft and helicopter on board operating at different weather conditions and at nighttime are the next steps in improving carrier operation. Chinese naval aviation has a long way to go in developing its combat capability, so will be sure to continue to see its progress next year. I think it’s also interesting that we have yet to see photos of CV-16 leading a large flotilla with numerous escorts like 052C/D and 054A, so that’s also something to look to see in 2016. The Chinese navy has to do all of this with very little help from other carrier operating navies around the world, so it has been deliberately ramping up operation for the past 3 years. It may take several more years to see the things I’ve listed here.<br/>
<br/>
The rest of the surface fleet programs have also been progressing well like previous years. The 4 new 052C ships have now all joined service as No. 150 to 153. Two more 052Ds (No. 173 and No. 174) have also joined service. The main gun PJ-38 has also recently did a comprehensive round of firing tests. The 052Ds are equipped with the latest VLS, multi functional radar, variable depth sonar and PJ-38s, so they represent quite a major improvement in capabilities over 052C despite sharing the same hull. There are probably at least 5 more 052Ds from JN shipyard and 2 more from Dalian shipyard that are under construction. We will probably also start seeing progress of 055 in one of these shipyards next year. Amongst the 054As, a couple of more joined service this year and more modules have also appeared. They are also installed with the new VDS. The production of 054As has already exceeded what was expected originally, allowing the older Jianghu ships and the 4 Jiangwei ships to be decommissioned. It will be interesting to see how many more 054As ships are built when many have expected PLAN to move production to a newer 054 variant. Similarly, Type 056 corvettes have also continued to be produced in large numbers this year and they are expected to replace the roles of Type 037s in patrol, sub chasers and ASuW. And finally, the 4th Type 071 recently joined service as No. 988.
Aside from the surface combatants, the replenishment fleet has also seen a huge boom this year. Most recently, the 40K+ ton displacement Type 901 AOR was launched. This type of shape is significant, because it’s expected to be the primary AOR for China’s future carrier fleet. It is much larger than China’s existing Type 903 class of AORs. Also, it is powered by gas turbines instead of diesel engines on the Type 903 AORS, allowing for much higher speed to keep up with the rest of carrier fleet. It also has more resupply gantries located in the middle of the ship than Type 903, which allows for underway refueling with more ships. At the same time, both HD and GSI shipyard have continued to build and commissioned Type 903A ships.
There were 3 Type 903A (No. 960, 966 and 963) have joined service this year. There are at least 2 other one launched and another building. The Type 904 large store ships also had a lot of activity this year. There were 2 Type 904B ships (No. 961 and 962) that joined service year. These additional ships are probably there to supply the increasing amount of activity that China has in South China Sea and East China Sea. So overall, this was a really active year for China’s replenishment fleet. A couple of the older replenishment ships will probably retire over the next couple of years, but the increasing number of large ships joining into service will allow for greater power projection capabilities and also supplying near by islands.
Finally, China’s coast guard fleet construction activity has continued this year with some of the largest cutters joining service. There were 12000-ton class, 5000-ton class, 4000-ton class and numerous 3000-ton class cutters getting launched and commissioned. A lot of ships seem to have conflicting roles, but they were originally created for different agencies and for provincial bureaus. I think that most of the programs are nearing conclusion at the moment. Until the next 5-year plan gets developed with similar number of projects, we probably will not see this same level of expansion for a while.
As a whole, an interesting year with news from both the navy and air force. I will be looking to follow up on most of these programs next year.
Unknownnoreply@blogger.com3tag:blogger.com,1999:blog-2810814791836407713.post-80768596535027581612015-12-05T12:13:00.002-08:002015-12-05T12:13:39.161-08:00ASBM program and Su-35 exportI came across a really well down book by Andrew Erickson on China's ASBM development. The book can be found <a href="http://www.andrewerickson.com/wp-content/uploads/2014/01/China-ASBM_Jamestown_2013.pdf">here</a>. It was written by 2013, but most of the content is still very up to date. It does a good job of talking about ASBM development, motivation, capability and China's satellite system. Since then, I think the only major update is the unveiling of both DF-21D and the previously unknown DF-26 in China's Victory parade in September. That shows a much greater potential usage than just Taiwan scenario or even around disputed islands in South and East China Sea.<br/>
<br/>
At the same time, the other news that came out this past week is the finalization of Su-35 export. The discussion seemed to have started way back in 2008 and really picked up since 2012. I think Su-35 is an interim solution to provide advanced capability to PLAAF beyond their existing flanker fleet while CAC is completing the development of J-20. I see it as any improvement over China's domestic J-11s, but not something that will be a legitimate solution to F-35 and other 5th generation aircraft.Unknownnoreply@blogger.com10tag:blogger.com,1999:blog-2810814791836407713.post-81606038937253812422015-11-24T16:06:00.002-08:002015-11-24T16:06:15.803-08:00China's first oversea baseI will keep this short. We have report that China has signed a ten year deal with Djibouti for its first oversea naval base. Andrew Erickson provided a good analysis of today's development <a href="http://www.andrewerickson.com/2015/07/china-signpost-91-djibouti-likely-to-become-chinas-first-indian-ocean-outpost/">in this article</a>. The location makes a lot of sense since China has been making port calls there as part of its missions in Gulf of Aden. This <a href="http://www.jamestown.org/programs/chinabrief/single/?tx_ttnews[tt_news]=36659&tx_ttnews[backPid]=25&cHash=010590e601#.VlT6PctYD7A">2010 Jamestown article</a> did a good job of exploring what had been an expanding support network for PLAN up until that point. Certainly, as Chinese naval influence grows in this region with more port calls, patrols and joint exercises, I think there will be more arrangements where China establishes what looks like oversea base (even if they are not called that).Unknownnoreply@blogger.com4tag:blogger.com,1999:blog-2810814791836407713.post-77751903788618708352015-11-07T11:16:00.001-08:002015-11-07T11:16:34.410-08:00My thoughts on COMAC C919Most recently, COMAC (Commercial Aircraft Corp. of China) rolled out the first C919 off the assembly line to eagerly awaiting media. The question as we go forward is how successful will C919 be or how successful can it be? It has already pushed back it maiden flight from 2014 to 2016 (which is not too uncommon in aerospace industry) and first delivery to 2018.<br/>
<br/>
AVIC1 has had a long history of supplying parts to both Boeing and Airbus airliners. China's large domestic market has even resulted in final assembly lines inside the country for A320 (and also A330 and B737 going forward). Even so, building a successful modern airliner require building up and maintaining a complicated supplier network, production systems, assembly lines, marketing network and after sales service centers. On top of this, the process of getting FAA certification for airliner is a tremendous undertaking. China had very little experience before it started ARJ-21, which resulted in significant delays while trying to get CAAC certification. Now 8 years after the initial planned service entry, the first ARJ-21 is finally about to enter service later this year without FAA certification. China certainly learnt a lot from ARJ-21 project from all I have read and is unlikely to have the sam delays getting CAAC certification in the C919 project. However, the thorny issue of have FAA recognizing CAAC certification still needs to be resolved before both aircraft can be sold to the wider markets. If they cannot be resolved, then C919 simply would not be able to land in large part of the world which requires on FAA or EASA certification. So until then, C919 is restricted to the domestic and surrounding markets. Based on COMAC's ARJ-21 delays, it's reasonable to assume that most airlines would prefer to wait until closer to certification before making decision on purchasing C919.<br/>
<br/>
From all of this, I think it's quite clear the tremendous undertaking to go straight into C919 without even achieving a successful production cycle in the less competitive regional airliner segment which is currently dominated by Bombardier and Embraer. Up to now, C919 has been able to get large amount of orders (about 500) based purely on the size of its domestic market. As seen in the Russian project of MS-21 and Superjet-100, it is far easier to get export deals in the regional jet segment than the A320/B737 segment. Even an experienced aircraft maker like Bombardier has struggled with breaking into this segment and is loosing a lot of money and facing long delays in the CSeries project. Bombardier made the entry into this segment trying to take advantage of the generation gap between A320/B737 and next generation of regional jet by utilizing the next generation engine to achieve about 15% improvement in operation cost over A320. However, Airbus quickly countered CSeries and C919/MS-21 threat by coming out with the A320NEO upgrade by offering the same new engine options, new sharklets and some other smaller upgrades. That has more of less crushed CSeries sales prospects and given it a lead over the improve B737MAX upgrades. At this point, both C919 and MS-21 are going up against the two entrenched players with significant resource advantage. Unlike the CSeries, C919 (and MS-21) can at least secure large quantities of domestic orders and also have significant government support. COMAC does not have the marketing, production, certification and sales experience that Airbus and Boeing do. It is always hard to knock off established players without advantage in product quality. Both airbus and Boeing have significant backlogs, so C919 maybe able to get more orders in both domestic and export market if it is able to have fewer future delays and obtaining FAA certification. I think if it can get FAA certification and several hundreds export orders, this would be considered a successful project. After all, Airbus's first project A300 only achieved 500+ sales.<br/>
<br/>
More importantly, I think China sees this a significant initiative in lifting its civilian aviation industry. I've talking many times in the past about how China's shipbuilding industry allows it to quickly and cheaply build up China's naval force. China's aerospace industry simply doesn't have close to the same production capacity as Lockheed Martin and Boeing. I read that COMAC aims to lift C919 annual production rate eventually to 150 aircraft a year. Even though that's rather small compared to A320 production of 60 a month, it would still be a huge undertaking for COMAC and AVIC1. That kind of huge leap in production quality and capability would be transferable to military aviation projects. In the end, I think China is willing to loose money on both ARJ-21 and C919 project for these reasons.<br/>
<br/>
After C919, COMAC and Russia UAC is said to be joining forces in the C929 project. It seems like the technology used in this project may be behind that of B787 and A350. Both of which represent the cutting edge of modern civil aviation. So, it's hard for me to see how they could compete for much outside of domestic project. In choosing to partner up with UAC, COMAC is signaling it does not think it's capable of developing a commercially viable C929 project on its own. All of which leads to me think it would be best for China followers to temper expectations on the C919 project.Unknownnoreply@blogger.com22tag:blogger.com,1999:blog-2810814791836407713.post-5366110835579295232015-09-20T06:15:00.001-07:002015-09-20T06:15:27.279-07:00J-20 and more thoughts on 5th generation projectsMost recently, a 7th prototype of J-20 project (No. 2016) appeared and made its maiden flight on September 18th. It’s been 9 months since the last prototype had come out, so this new prototype is a sign that the program has not hit any major stumbling block and was just going through the next iteration in its development. As a refresher, 2 prototypes (No. 2001 and No. 2002) came out and flew in 2011. They were probably the demonstrators of this program. Over 2 and half years later, the 3rd J-20 prototype (No. 2011) came out and was followed by 3 more prototypes (No. 2012, 2013 and 2015). They had some major redesign and changes compared to the demonstrators. So they should be considered the first pre-production prototypes and were probably produced in the same batch. CAC and CFTE have been testing them since that time. I expect that more J-20 prototypes will be coming out in the next few months, since they seem to be building them in batches on this and past CAC project. Compared to the last batch of J-20s, the most noticeable changes have been on the DSI bump and the engine nacelle. The DSI bump looks to be a little larger and people have speculated that some EW equipment may be installed inside. From the relatively few changes between the batches, one can surmise that the J-20 design is more or less frozen.<br/>
<br/>
Indeed, there have already been speculations that the first production J-20s will come out next year to be tested and evaluated by FTTC. While I think that is certainly possible, I think it is also best to tamper one’s expectations and expect some problems along the way. Every 5th generation projects so far have experienced some bumps along the way. The PAK-FA project had fire on one of its prototypes and still has not flown a new prototype since. IAF have continually complained recent years about the technology and progress of PAK-FA. The F-22 and F-35 projects are far more open, so there were many reports of issues along the way. One would expect J-20 to encounter similar issues along the way even if those reports only come out in the rumour mills of Chinese military forums.<br/>
<br/>
With everything that we can see, I think that CAC has been doing a great job with the J-20 project. At this point, I already consider J-20 project to be ahead of PAK-FA in both the design and timelines. In terms of design and technology, J-20 looks to be better configured for stealth from most profiles vs PAK-FA. The next generation AESA radar and the rest of electronic suite are already been deployed J-10B/C and J-16 compared to lack of such Russians platforms. Even the next generation missiles (like PL-10 and PL-15) seem to be further along in development and deployment than similar Russian systems. PAK-FA only seems to be using a more advanced engine at this phase of testing. Considering that the Russians started to research on 5th gen fighter jet in the 80s and first flew PAK-FA a year earlier than J-20, this does not speak very well of Russia’s aerospace industry.<br/>
</br>
For the past year or two, I’ve read numerous articles coming out of India that complained about the technology, cost and lack of their work share in the PAK-FA project. Since then, there was a fire on one of the PAK-FA prototypes when they were giving a flight demonstration to Indian delegation and have not shown a new prototype since. There have also been numerous online posts about the build problems and quality issues with those prototypes. Now most recently, I’ve also seen a report where India is thinking of pulling out participation in the development of PAK-FA and just buying them straight out of Russia. They probably realized Russia was unwilling to share its most sensitive secrets so they needed to devote more of their R&D resources on their domestic project MCA. At the same time, it also appears that some in IAF is favouring for purchase of more Rafael and less PAK-FA. There are numerous components of PAK-FA project like stealth and propulsion, which are not up to par with the standard established by F-22. If the leap in technology over Rafael is not big, then it makes all the sense to buy the more of the mature platform. Of course, that could also create a disastrous scenario for IAF if J-20 and FC-31 turn out to be much better than Rafael. <br/>
<br/>
If all goes well, J-20 looks to join service in a couple of years. This version of J-20 will be quite underpowered and have to wait a few years before getting WS-15 engine. That would be the next major change for J-20. It looks like the second demonstrator or first pre-production prototype of FC-31 may be coming out soon. I think most people expect some significant changes vs the first demonstrator. In the recent years, CAC has devoted most of its resources on J-20, whereas other projects like J-10B/C have been a little slow in development. SAC is tasked with the development of numerous flanker variants and UAVs. It may not be able to devote the same amount of resource on FC-31 project, so I would expect the progress on FC-31 to be slower than J-20. Even if FC-31 becomes ready several years after J-20, it may still become available to export market at the same time as PAK-FA (after Russian and Indian orders). So I think FC-31 could capture a good chunk of the non F-35 market.Unknownnoreply@blogger.com8tag:blogger.com,1999:blog-2810814791836407713.post-81831565417272749552015-09-06T21:59:00.002-07:002015-09-06T21:59:47.325-07:00More on Yuan submarine.Recently, I saw a good article that Chris Carlson posted on <a href="http://news.usni.org/2015/08/31/essay-inside-the-design-of-chinas-yuan-class-submarine">USNI regarding Yuan Submarine</a>. Although I have not attempted to do any GE measurement of Yuan that I had done with 093 class, I find his assessment on the size of the Yuan submarine to be well done. I previously would have estimated the ratio of Yuan's beam to that of Song at higher than 8.4 to 7.5 based on photos, but he uses a very thorough approach, so I will accept his numbers until anything else comes up.<br/>
<br/>
On the topic of China using Yuan as an anti-ship cruise missile platform, I think he is also on the money here vs the other USNI author. At this point, China has put a lot of investment into different types of torpedoes whereas much less noise have been made about submarine launched anti-ship missiles, so I think their preferred method of attack on surface ships is going to be through blowing a whole underneath rather than hitting something on the midsection. There have not been any sighting of submarine launched anti-ship subsonic missile that's newer than YJ-82. On top of that, it's highly unlikely YJ-18 is designed to be launched from torpedo tube. With the specs of Chinese navy's new CCL VLS system, I think the diameter of YJ-18 is likely to be larger than 53 cm which is the requirement to fit inside the torpedo tube.<br/>
<br/>
And I'm waiting for his article with Andrew Erickson regarding Chinese supersonic ASCMs to come out.Unknownnoreply@blogger.com9tag:blogger.com,1999:blog-2810814791836407713.post-36079592413312399482015-09-06T20:50:00.004-07:002015-09-06T20:50:32.642-07:00Victory Parade and Chinese politicsMost recently, China had a Victory parade to celebrate the 70th anniversary of war against Japan. As part of this parade, China rolled out its latest ballistic missiles, cruise missiles, armored vehicles, UAVs, helicopters, fighter jets and special missions aircraft. All of the displayed weapon systems are believed to be in service. For the first time, China publicly displayed DF-21D and DF-26, which are the ballistic missiles designed for attacking moving targets like a carrier. Certainly, I have posted numerous blog entries in the past regarding China’s ASBM program and the challenges around it, so this has always been an area of interest for PLA followers. We have now seen these ASBM missiles on display and know that it is in active service. What we don’t know is how good China is at finding a fast moving carrier group in the middle of the Pacific Ocean, tracking it and then engaging it. Certainly for a missile DF-26 which will have longer range and higher re-entry speed than DF-21D, the engineering challenge of finding carrier upon re-entry and maneuvering to hit something that can move at greater than 30 knots is very daunting task. They also displayed DF-5B, which is China’s first public display of an ICBM with multiple nuclear warheads. The parade also displayed the DF-10A LACM (land based version of KD-20 LACM) and various other short and medium ranged ballistic missiles. The second artillery certainly had a field day at this military parade. Comparing this to the pictures from China’s military parade in 1984, it was quite interesting how backward they were back then. It still had the same nationalistic tone and show of strength from all the Chinese leaders.<br/>
<br/>
Behind all of this, it’s a time of uncertainty and worry for the current Chinese leadership. China’s major leaders of past and present were all there (even ones I didn’t realize was still alive) to present a united front. By this point, most people have seen the crash of Chinese stock market. The Chinese economy has also slowed down a lot by this point. Nobody can predicate what will happen there or anywhere else, but these parades are used to show the power and accomplishments of the communist party and distract people from the worries of economic and other problems. I’ve read numerous articles on the politics of recent events. While I’m not sure about their accuracy, it does paint a picture where the younger generation of leaders is still battling the older generation in their efforts to carry out reforms. China’s previous paramount leader Hu Jintao was quite limited in his power due to the continued influence of his predecessor Jiang Zemin. It seemed like the leadership of Xi Jinping and Li Keqiang would get more freedom in their efforts to bring a more market based economy to China since taking control 2 years ago. Reading about their pilot free trade zone in Shanghai, the attempted deleveraging of the credit bubble and wider trading band of RMB, I have gotten the feeling that Li Keqiang has some pretty good ideas about resolving some of the problems in the Chinese economy. In the past couple of month with the worsening stock market and rapidly slowing economy, you can really see a lot of his moves getting reversed. (If you listened to any of Donald Trump’s speech recently, you would hear about the greatest one-day devaluation of RMB of 2%.) To clear up certain misconceptions before we continue: China does have its own foreign exchange market similar to EBS, which allows RMB to be freely traded within the 2% daily band for entities inside China. It just has capital control preventing money from easily flowing outside the country (like Brazil, Korea, India and numerous other nations), so does not appear free-floating to outsiders.<br/>
<br/>
Throughout PRC’s history, elderly members of the politburo have been more reluctant toward reform efforts. Even when the all-powerful Deng Xiaoping was pushing his reforms in the 80s, other party elders like Chen Yun and Li Xiannian limited Deng’s efforts as soon as troubles started. The most reform minded Chinese leaders of their day Hu Yaobang and Zhao Ziyang were pushed out and humiliated after the student protests of 1987 and then the infamous 1989 TianAnMen Square protests. In a functional economy, we have the boom and bust cycle where credit expand during the boom and contract during bust causing problems in the economy. The bust part of cycle allows the inefficiencies and ailments of the economy to be removed. It is natural for any reform and deleveraging economic efforts to cause a period of economic and social problems. The last time China really allowed the bust to happen is during the Asian economic crisis of 1997 and 1998 when the inefficient state owned enterprises were allowed to fail. At the time, unemployment rate, early retirement and crime rate skyrocketed in the country. The FaLanGong movement arose during this period. Since then, China enjoyed 10 years of good economic growth, a slowdown in 2008 and another 6 years of economic growth. While this was happening, it has been accumulating unsustainable amount of debt and credit creation.<br/>
<br/>
In May of 1989, Zhao Ziyang, who was nominally China’s president at the time, told the visiting Soviet leader Gorbachev that he was not really in charge of China in real decision-making. After taking over in 1987 from Hu, Zhao needed to survive 10 years against the pressures of the conservatives inside the politburo, but lasted less than 2 years after refusing to participate in crushing the student movement. Since then, most of the reform efforts have been economically related and is badly needed in China right now. If reform minded leaders inside the day-to-day leadership get pushed every time there is a setback and become blamed by the elders for economic problems, it’s hard for me to see how this new generation of leaders can get anything done while Jiang Zemin and Li Peng are alive and functioning. Looking beyond China’s display of military power in this parade, China’s biggest threat to the world is an economic crash that slows down its major trade partners and vacation destinations.Unknownnoreply@blogger.com3tag:blogger.com,1999:blog-2810814791836407713.post-31719978498506489702015-07-20T06:58:00.000-07:002015-07-20T06:58:08.103-07:00Update on Chinese Navy: MLP and ZubrMost recently, a new amphibious type of ship entered service with Chinese navy that looks to be similar to US’s Mobile Landing Platform. You can see it from the picture below.<br />
<a href="http://postimage.org/" target="_blank"><img src="http://s21.postimg.org/4pkyf9kxz/203_145758_564033.jpg" width="500" /></a><br />
<a href="http://postimage.org/" target="_blank"><img src="http://s15.postimg.org/nfjdexltn/203_145755_181892.jpg" width="500" /></a><br />
As shown int he pictures, the most obvious usage of this ship (Given the number 868) has already been shown in photos where a Zubr class hovercraft boarded it. Based on the current photos, only one Zubr class hovercraft can fit in the platform area although it could also possibly also hold a Type 726 hovercraft (Chinese version of LCAC). PLAN had previously signed contract to purchase 4 Zubrs from Ukraine with 2 produced in Ukraine and the other 2 in China. The 2 from Ukraine were both delivered prior to Russia’s takeover of Crimea, but future dealings for Zubrs will most likely be with the Russians. At the time of purchase, it looked like they could be used in any Taiwan conflict scenarios or any amphibious operations in South China Sea. More blue water amphibious marine expeditions required the Type 071 class. The induction of No. 868 certainly allows more expanded operational scenario for Zubr, but the scale of its usage is really limited by the number of such MLPs that PLAN will likely induct in the future. <br />
<br />
This looks to be a vote of confidence for Zubr class in China. I think that China will be building more Zubr with Russian help (especially on propulsions) after the first batch of 4 joins service. This huge commitment for Zubr comes after PLAN had already inducted the smaller Type 726 into service. That would indicate Zubr is bringing some unique capabilities that Type 726 launched from Type 071 simply cannot provide. As with No. 868, we will have to wait to see its other usage cases, since PLAN is unlikely to have ordered such a ship just to carry 1 Zubr around.
Unknownnoreply@blogger.com13tag:blogger.com,1999:blog-2810814791836407713.post-6859506214738781312015-06-27T07:56:00.001-07:002015-06-27T07:56:41.692-07:00Export of Yuan SubmarineVery recently, an article from <a href="http://www.bangkokpost.com/news/security/604452/chinese-win-bid-to-supply-subs-to-navy">Bangkok Post</a> broke the news that China has own the competition to supply 3 submarines to Bangkok Navy. While this is China's third export deal of conventional submarine in the past year, this is the most significant one in terms of the competitiveness of the competition. Since China and Thailand has a history of military transactions, this deal is unlikely to encounter the kind of scrutiny like the Turkey long range SAM contract.<br/>
<br/>
At present time, there are at least 12 Yuan submarines of different variants (4 039As and 8+ 039Bs) in service with PLAN across 2 flotillas. They and the Type 039 Song submarines are the work horses of PLAN. After a rapid production run the last couple of years, the production has slowed in the past year. While this is the most capable of China's mass produced conventional submarine, it is not considered to be as classified as when it first came out. In the past year, Admiral Greenert, Chief of US naval operation, was allowed to go inside one of the Type 039B. While this generally reflect PLAN's effort to be show greater transparency with its USN counterpart, it also indicates 039B is not held with the same level of secrecy as Type 093 nuclear submarine. Since late 2013, a model of S-20 was displayed in various arms exhibitions. From one of the exhibitions, the S-20 is shown to have submerged displacement 2300 ton with maximum dive of 300 m. I was always under the impression that 039B was larger than this, so S-20 may turn out to be a smaller version of 039B.<br/>
<br/>
In late 2013, It was reported that China had received order for 2 Ming class submarines (Type 035B) from Bangladesh. This was certainly surprising news since Chinese shipyard have not produced such submarines since early 2000s. Rather than selling 2 from its existing fleet, these were to be new builds. It's not clear which shipyard is building these submarines, since I have yet to see any pictures. While the type of submarine was surprising, the fact that China was selling to one of its traditional clients was not. Then in early this year, Pakistan announced that it will purchase <a href="http://www.dawn.com/news/1173042/govt-endorses-summary-to-get-8-submarines-from-china-defence-committee-told">8 submarines</a> from China along with 4 frigates. None of this was surprising, since reports of export of 6 to 8 Yuan submarines (S-20P for Pakistan?) had been rumoured for several years after Pakistan's U-214 deal failed due to funding issues. Since Pakistani Navy had always been purchasing advanced European submarines up to this point, it was significant that Pakistani Navy found Yuan submarine as suitable purchase. Even so, China's traditionally strong relationship with Pakistan was important in this deal.<br/>
<br/>
While, the order from Thailand is not as large as Pakistan, it involved more competitors based on the various articles on this sale. With offers from Germany, South Korea, Russia, Sweden and France, S-20T won against some quality competition. None of this means Yuan submarine is the most advanced or the quietest conventional submarine out there. The article was very clear in that Yuan was picked because it the best value for money. In other articles, they also mentioned China's willing to transfer technology and provide training. I would think that other nations are willing to provide training and ToT also, so I think the bigger draw is China's cost advantage. The article also mentioned Chinese submarines can stay in the water longer and had superior weaponry and technology. That could mean Yuan submarine's AIP engine showed good performance in trials. The superior weaponry probably points to the torpedoes and submarine launched anti-ship cruise missiles that China has developed in the recent years. Traditionally, the Chinese submarines have been more noisy than western submarines. While this export variant of Yuan submarine is unlikely to the quietest in the competition, its cost advantage along with comparable performance in other areas won over Thailand. It's worth noting that China's 054A had lost out to South Korea in Thailand's frigate competition despite similar cost advantage. So this shows Thailand would not pick S-20 if it did not believe in its performance.<br/>
<br/>
Conventional submarine is one of the most lucrative sector of defense industry. West European and Russian submarine makers had been winning most of the export competitions in the past, so it bodes well that S-20 could win one of such competitions on more than just cost advantage.Unknownnoreply@blogger.com7tag:blogger.com,1999:blog-2810814791836407713.post-40919308438887653502015-05-25T14:19:00.001-07:002015-05-26T04:52:52.693-07:00Update to the Chinese carrier projectI have not made much updates recently due to travel and busy work schedule, but I did see this picture today which was really interesting. Edited: It turns out the original photo I posted was a CG, so only the one below is real. This one shows 4 10x J-15s on board. We also have photo of 5 J-15s flying together.<br />
<a href="http://postimg.org/image/a5zpoo6hf/"><img alt="106 Apr26" border="0" src="http://s13.postimg.org/69mdsolhz/106_Apr26.jpg" width="500" /></a><br/>
There are various conflicting reports on this particular training exercise, but it seems like CV-16 and escort fleet left early April for the first training exercise of the year and may have spent time in South China Sea before coming back. The J-15s on board CV-16 are from the first production batch numbered 10x. We've seen up to No. 109 in J-15s, so they do have up to 10 production J-15s available to be deployed. The most important part to note here is that they have moved past flight testing with the same 2 or 3 J-15 prototypes.<br/>
<br/>
Again, it took two and half year for PLAN to get to this point with CV-16, so this is still a very deliberate project for them. Based on recent interviews, it looks like they are trying to move forward at a measured pace to avoid any major accidents. As more J-15s are produced, it is interesting to see CV-16 with increasingly crowded flight deck.Unknownnoreply@blogger.com5tag:blogger.com,1999:blog-2810814791836407713.post-63638752701072044102015-04-06T07:58:00.000-07:002015-04-06T07:58:03.813-07:00Cutter progress in Chinese shipyardsI last wrote about China's expansion of civilian maritime force <a href-"http://china-pla.blogspot.com/2013/01/chinas-recent-expansion-of-civilian.html">here</a>. Due to recent requests, I'm doing an update. Please note that as with all else Chinese shipbuilding related, the various programs do change and some new builds may have been mixed. This is my best attempt at summarizing what has happened in the past 2 years.<br/>
<br/>
In the first part of that last post, I wrote about the expansion of CMS (Chinese Maritime Surveillance) provincial branches. From the table in that section, 36 cutters of 1500 ton, 1000 ton and 600 ton class were built for various provincial flotilla of CMS. Much of the building and launching activities happened in 2013 and 2014. HP shipyard, which builds most of the larger cutters, have delivered all of the cutters that they were contracted to build by middle of 2014. WC shipyard seems to have completed its share too. Even the smaller shipyards seem to have finished most if not all of their ships. So at this point, it looks like the provincial expansion have completed.<br/>
<br/>
After this first expansion of provincial fleet, the Chinese Maritime Surveillance, now under the Coast guard, is undergoing a further expansion as mentioned in the second part of that post. That program consists of 2 12000 ton cutters to be built by JN shipyard, 4 5000 ton cutters to be built by WC shipyard, 4 4000 ton cutters to be built by HP shipyard and 10 more 3000 ton cutters to be built by HP and WC shipyard. Most likely, RFPs were sent out to the various shipyards around the country, but only a few shipyards in China are capable of building these larger cutters. The 2 12000 ton cutters were launched at JN shipyard this past few months and they are probably the first major cutter projects that JN shipyard has worked on. They are given the designations Haijing-2901 and 3901. It's unclear if more of this class will be built. The 4000 ton class cutters have been all delivered by HP shipyard as Haijing-1401, 2401, 3401 and 3402. It looks like those 3000 ton class cutters have now all been launched and commissioned into service with Coast guard. 3 of them are with the North Sea Flotilla, 4 with East Sea Flotilla and remaining 3 with South Sea Flotilla. In addition, works have been under way for the 5000+ ton class ships cutters with 3 of them (Haijing-1501, 2501, 3501) launched in the past few months at WC shipyard.<br/>
<br/>
All of the work by HP shipyard were completed by the end of 2014, whereas WC is still in the middle of completing the 5000 ton class cutters and just most recently completed work for 3000 ton class cutters. All of this is somewhat surprising, because WC shipyard had taken the lion share of cutter constructions in the past, while HP is new to the game. I think the experience that HP gained from the 054A and 056 class projects really improved their ability in delivering ships on time. They are now rewarded with large orders for both naval ships and cutters. Back in 2013, CMS had joined the coast guard along with FLEC and customs as part of a consolidation of China's large maritime surveillance programs. Before that point, only the coast guard ships were allowed to be installed with naval gun. As part of this consolidation, all the newer large cutters for various arms of the consolidated Coast Guard are installed with naval gun. With all the maritime issues that China has with its neighbours, I think the ability to install naval and machine guns on these cutters is definitely a reason that pushed for the consolidation of the 4 agencies.<br/>
<br/>
On top of the work for CMS, FLEC also had money to expand its fleet with 3000 ton and 1000 ton cutters. Since FLEC also merged into the coast guard, I found it hard to hard to determine which of the newer cutters are for its orders. There are a couple of new 3000 ton class cutters launched at both HP/WC shipyards like 3301 and 2301 that seem to fit the profile.<br/>
<br/>
Of the 2 smaller agencies that consolidated, HaiGuan (Chinese customs) had an order for 3 1500-ton class cutter with electric propulsion and 9 600 ton class cutters. The 1500 ton class cutters are to be built by HP shipyard. The first of which was launched last year and has now been painted with Haijing-44104. The 600 ton cutters are built by Guijiang shipyard. Guijiang shipyard handles a large quantity of Coast guard's 600 ton class cutters. They were the first to built Type 618 and improved versions of Type 618 cutters for the old Chinese coast guard. They have continued to built Type 618B cutters for the new consolidated coast guard.<br/>
<br/>
Since the last update, the majority of the programs have been completed or well under way. The old CMS agency has been delivered with most of the ships it had ordered, whereas FLEC still seems to be waiting for all of its ships. The new consolidated Coast guard agency have since started new programs. A year ago, they started projects for Type 818 patrol vessels (3000 ton class) and Type 718 cutters (2000 ton class), HP shipyard signed for 4 of the Type 818 and 5 of Type 718. It sounds like Hudong, guijiang and Zhejiang are also participating in these 2 programs. WC shipyard's involvement was not clear, although my guess is that it will be building them too. So, the Chinese coast guard build up is continuing over the next few years, but probably at a slower pace than the past 2 years.Unknownnoreply@blogger.com0tag:blogger.com,1999:blog-2810814791836407713.post-91158712771083539752015-03-21T06:30:00.001-07:002015-03-21T06:30:36.296-07:00Myanmar and KokangIn this past month, Myanmar air force has apparently waded into Chinese territory 3 times as part of its ongoing struggles with Kokang rebels. In the most recent time, bombs were dropped which killed 5 Chinese citizens. Due to the fact that the vast majorities of Kokang population are ethnically Han Chinese and use RMB as their currency, there is understandably a lot of sympathy in China toward the plight of Kokang. Many people have compared this to Russia and Crimea and others wonder if China should do more in this conflict.<br/>
<br/>
As usual, China keeps to its official stance of not interfering with another country’s internal affairs while building up air defense capabilities in the border area. China painstakingly makes it clear that it’s not supporting Kokang rebels causes, because it has relatively good relationship with Myanmar and does a lot of business in the country. In the future, it is also possible that China would want to set up base in Myanmar to access Indian Ocean. So it should be quite understandable that PLA does not devote much resource in this area. There is 2 regiments stationed in the area, but they are quite a distance away from where the bombings took place. A lot of people were wondering about the readiness of PLAAF to respond to intrusions, but it seems like they really didn’t have that much time based on where the intrusions happened. <br/>
<br/>
The interesting part is that Myanmar first reacted to these bombings by putting the blames on the rebels and absolving itself of all responsibility. They have since toned down their accusations and may have even offered compensations to the victim’s families, but I think they really looked quite foolish in the process. A swift apology and some kind of pledge to investigate the matters would have done a lot to pacify the anger in China right now. As it is, the Chineses gov’t is under pressure to do something.<br/>
<br/>
So far, it looks like they have told Myanmar that this kind of action is not acceptable and will not be tolerated. And I think that if China wants to be the leader in this region, it certainly cannot allow repeated incursion of its airspace and bombing of its citizens. The way to do that is by building up more air defense weapon systems and installing more early warning radar in the range. If China’s radar cannot reliable track Myanmar’s Mig-29s, then they need to improve those radar systems. And if another deadly bombing does occur, then they probably need to launch strikes against certain Myanmar military targets. Other than that, it is in China's interest to keep this as low-key as possible.Unknownnoreply@blogger.com0tag:blogger.com,1999:blog-2810814791836407713.post-53433633029578747012015-03-07T07:46:00.003-08:002015-03-07T13:09:48.086-08:00What's most shrouded in secrecyThe Chinese navy has long been accused of not showing enough transparency. While that has certainly really improved in the recent year, there are still plenty of areas that's hard for a blogger like myself to follow. Certainly, most of the surface combatants are easy to track, since many photos are released of them. Most of the subsystems and weapon systems on these ships are also quite transparent with some version of them offered for exports. There are some many news reports giving even more information on various naval ships and their subsystems. So which programs are noticeably absent from all these photos and news releases?<br/>
<br/>
The most obvious answers would be their strategic platforms. Certainly, CV-16 is a strategic platform, but it also happens to be one of the more transparent programs due to how it has captured the imagination of the ordinary people. At this point, I don't see them introducing any significant secrecy to CV-16 or aircraft carriers in general due to the excitement it has generated. Certainly, the nuclear submarine programs are probably the most secretive platforms amongst all of the naval ships. We very rarely see pictures of under construction nuclear submarines, but we do get some pictures of them at the naval bases and out on patrols. Also, 093 was officially declassified a few years ago, which allowed for some more pictures to come out. As shown in my previous blog entry, we get enough information about 093 and 094 from China themselves and Google Earth photos in addition to ONI reports to make some educated guesses on where they are at.<br/>
<br/>
So, what else are really hard to get any kind of useful information on? The first would be the ASBM project. I've written numerous articles on it back in 2009. Such articles were written based on work already done by Chinese bloggers on the same topic. Even though numerous articles were written by people like myself, Andrew Erickson and numerous other PLA followers, much of what we gathered were based on our observations of various support systems that were developed. Certainly, we get more information on China's satellite programs, ELINT programs and UAV programs than DF-21D missile itself. We know that it is an active program, but the actual operational status is unknown at this point. It certainly makes sense that such secrecy is given to this program because of its strategic nature against US aircraft carriers. Due to the amount of attention I've seen USN given to this program, it seems like China would be wise to continue the secrecy here.<br/>
<br/>
Secondly, What caused me to write this blog is the secrecy in China's torpedo programs. First thing to note is the different levels of transparency given to light and heavy torpedoes. We have not only seen many photos of Yu-7 carried by helicopters and launched by naval ships, but we've also seen export versions (ET-52) of Yu-7 and pictures of the Yu-7 seeker. It would make sense for Yu-7 to be more transparent since it's unlikely to be very helpful against nuclear submarine and more likely to be used to counter conventional submarines. At the same time, its kinetic performance can be estimated based on that of MK-46 and A244-S. Basically, the Chinese navy don't have as much to loose by giving Yu-7 greater transparency. It will be interesting to see if the next generation of light torpedo will be given the same level of transparency. It certainly seems like they are not investing as much in them. Heavy torpedo on the other hand have been extremely secretive. In the past 5 years, we've seen photos of Yu-6 and Yu-3A loaded onto conventional submarines. There have been no export versions of 533 mm torpedoes anywhere. There have been little to no articles on the usage and test firings of 533 mm torpedoes. Even the status and performance of a rather old torpedo like Yu-3A is completely off limits. I do suspect that they should have the necessary kinetic performance to sink conventional submarines and most surface combatants provided that the Chinese submarine can reliably track them. Based on that, it seems like these torpedoes will remain in service at least with the conventional submarines.<br/>
<br/>
Since the wide introduction of Yu-6 is the past decade, there have apparently been 2 new heavy torpedoes in development that are either in service of close to service Yu-9 and Yu-10. In case you are wondering, I just read them off reasonably reliable Chinese bbs sources that these torpedo programs do exist and have gone through test firings. These were probably done in China's underwater weapon test range in South China Sea. It's no wonder why China is so concerned about American spy aircraft and ships around that area. Considering that there have not been any photos of them anywhere, I certainly don't have any details on their kinetic performance. So, the question is why there are so much secrecy toward these 533 mm torpedoes. I think China has correctly identified USN nuclear submarines as their biggest threat. After all, Chinese submarines cannot leave their naval bases without getting tracked by USN subs. Even though the top speed and operating depth of USN subs are classified, I would imagine that China needs something like MK-48 ADCAP that can sustain high speed over long range to chase down a modern USN submarine. The actual performance of something like the MK-48 mod 7 CBASS is classified (as is its advanced processing capability), but i would imagine it's capable of chasing down and destroying Russian and Chinese nuclear submarines that are within certain range. So I do think these new torpedoes will take over from Yu-3A/6 as the primary weapons on the Chinese nuclear submarines. On top of that, USN aircraft carriers are extremely fast and well protected against strikes for anti-ship missiles. A heavy torpedo is sure to do much greater damage than even multiple hits from anti-ship missiles. Therefore, new heavy torpedo development would also have double strategic value in usage against carriers. Now, I'm not saying the Chinese nuclear submarines are quiet enough to get within torpedo launching distance of a USN carrier, but numerous ambushing conventional submarines equipped with new torpedoes would be credible threats. So, I think these usage cases against strategic platforms explain their classified nature.<br/>
<br/>
Another torpedo system that we have very little information on is China's version of ASROC. Since 054As have joined service, there have been many photos, articles and TV interviews revealing the many capabilities of this class of ships. We knew very early on that 054A's VLS could launch HQ-16 missiles and have seen many photos of live firing of HQ-16. However, it was only recently confirmed on Chinese online sources that these VLS could also fire anti-submarine missile (given possible designation Yu-8). We first heard on a TV interview of PLAN commander that such ability does exist, but I did not know at the time whether this Yu-8 was fired from the VLS or some other launcher. I just have not seen any photos of Yu-8 at this point. Based on articles regarding the new VLS on 052D, it seems like that VLS will also be capable of firing some types of anti-submarine missile. There are certain advantages to VL anti-submarine missile vs normal shipborne torpedo launchers, since it gives surface combatants additional quick reaction, standoff ASW capability on top of shipborne helicopters. As I mentioned, we are still waiting for first public photo of such missile.<br/>
<br/>
On top of the classified nature of torpedoes, information on the new sonar system that China has developed for its surface combatants and submarines are also classified, but not to the same degree. I think it's clear that the Chinese Navy sees ASW as its biggest weakness. They have spent a lot of money in developing sensors to track advanced submarines, but more resources is spent on the weapons against them. Even as they show more transparency, torpedo programs are still very secretive.Unknownnoreply@blogger.com4